Maintenance And Repair; Towing; Refueling; Preventing Fires - Brave VH9922 Manual Del Propietario E Instrucciones De Seguridad

Safety
✔
ALWAYS make sure that both ends of the log you are splitting are cut as square
as possible. This will prevent the log from sliding out of position while under
pressure. Logs should be 24 inches or shorter in length.
✘
NEVER try to split two logs on top of each other.
✘
Never pile logs to be split in a manner that will cause you to reach across the
log splitter.

Maintenance and Repair

✔
Follow all safety rules, because most accidents involving the operation, main-
tenance, or repair of products occur because the assembler/owner/operator
failed to observe basic safety rules or operating instructions.
✔
ALWAYS inspect your log splitter before each use. Make sure all nuts, bolts,
screws, hydraulic fittings, hose clamps, etc. are securely tightened.
✔
ALWAYS check the oil level in the hydraulic oil tank and engine reservoir.
✘
NEVER operate your log splitter when it is in need of repair or is in poor
mechanical condition.
✘
NEVER tamper with the engine to run it at excessive speeds. The maximum
engine speed is preset and is within safety limits.
✘
NEVER make alterations to your log splitter in any manner. Such alterations
may cause the log splitter to become unsafe and WILL VOID THE WARRANTY.
✘
NEVER attach a rope or extension to the control lever or add width or height to
the splitting wedge. Such ALTERATIONS may cause the log splitter to become
UNSAFE and WILL VOID THE WARRANTY.
✘
ALWAYS clean the unit after each use. If possible, store the unit inside or cover
it completely, if stored outside.

Towing

✔
Raise the support leg to the highest position when towing.
✔
ALWAYS check before towing to make certain your log splitter is correctly and
securely attached to the towing vehicle. Be sure that the ball hitch you are
using is the proper size for the hitch coupler on the log splitter (see "Specifi-
cation" section). Be sure the safety chains are properly hooked to the vehicle
leaving enough slack for turning.
✔
ALWAYS allow for added length of the log splitter when turning, parking, cross-
ing intersections, and in all driving situations.
✔
ALWAYS be careful when backing up. You could jackknife your log splitter if
care is not taken.
✔
ALWAYS disconnect your log splitter from your towing vehicle before attempt-
ing to use it.
✘
NEVER exceed 35 m.p.h. when towing your log splitter. Obey all state and
local regulations when towing on state and local roads and highways. Adjust
your speed for terrain and conditions, as needed. Be extra cautious when tow-
ing over rough terrain, especially over a railroad crossing.
Brave Products, Inc. 800-350-8739
6
✘
NEVER tow your log splitter when there is fuel in the engine's tank.
✘
NEVER allow anyone to sit or ride on your log splitter.
✘
NEVER carry any cargo or wood on your log splitter.

Refueling

✔
ONLY refuel the log splitter outdoors in a clear area void of gas fumes or spilled
gasoline.
✔
ALWAYS use an approved fuel container to carry gasoline.
✔
ALWAYS replace the log splitter gas cap and the fuel container cap securely.
✔
If gasoline is spilled, move the machine away from the area of the spill and
avoid creating any source of ignition until the spilled gasoline has completely
evaporated.
✔
Take a class B fire extinguisher with you when operating the log splitter in dry
areas as a precautionary measure against possible flying sparks.
✔
Always store gasoline in an approved, tightly sealed container. Store the con-
tainer in a cool, dry place. Do not store the container in a house or near any
heating appliance.
✘
Do not smoke or have open flames when refueling the engine. Do
not spill fuel. If fuel should spill, quickly wipe up the spill and allow
the excess to evaporate before continuing.
soaked rags are properly disposed of.
✘
DO NOT fill the gas tank while the engine is hot or running. Allow time for the
engine to cool down before refueling.

Preventing Fires

✘
NEVER operate the log splitter near a flame or spark. Oil and gasoline are
flammable and can explode.
✘
NEVER smoke while operating or refueling the log splitter. Gasoline, oil, and
even gas fumes can explode.
Important Notice
The log splitter is equipped with an internal combustion engine and should not
be used on or near any unimproved forest-covered, brush-covered, or grass-
covered land unless the engine's exhaust system is equipped with a spark
arrester meeting local or state laws (if any). If a spark arrester is used, it
should be maintained in effective working order by the owner and/or operator.
800-350-8739
Safety
Make sure gasoline
Brave Products, Inc.
7