Wayne Dalton 9100 Instrucciones De Instalación Y Manual Del Propietario página 13

4
Installing Q.I. Jamb Brackets
Measure the length of the vertical tracks.
Tools Needed:
Using the jamb bracket schedule,
None
determine the placement of the jamb
brackets for your door height and track
type. To install the jamb brackets,
align the twistlock tab on the quick
install jamb bracket with the quick
install feature in the track and turn the
bracket perpendicular to the track so the
mounting fl ange is toward the back (fl at)
leg of the track.
DOOR
HEIGHT
6'0" 64" TRACK
(1626 mm)
6'5" 69" TRACK
(1753 mm)
6'8" 72" TRACK
(1829 mm)
7'0" 76" TRACK
(1930 mm)
7'3" 79" TRACK
(2007 mm)
7'6" 82" TRACK
(2083 mm)
7'9" 85" TRACK
(2159 mm)
8'0" 4 SECTIONS
88" TRACK (2235 mm)
8'0" 5 SECTIONS
88" TRACK (2235)
5
IMPORTANT: RIGHT AND LEFT HAND IS
Tools Needed:
ALWAYS DETERMINED FROM INSIDE THE
None
BUILDING LOOKING OUT.
NOTE: For door section identifi cation see
page 4.
TorqueMaster
are marked right and left hand. Uncoil the
counterbalance cables and make sure you
place the right hand cable loop on the right
hand milford pin and place the left hand
cable loop on the left hand milford pin.
Insert a roller into bottom bracket of the
bottom section and insert another roller
at #1 end hinge at the top of the bottom
section. Repeat for other side.
NOTE: Verify astragal (bottom seal) is
aligned with door section. If there is more
than 1/2" excess astragal on either side,
trim astragal even with door section.
Please Do Not Return This Product To The Store. Contact your local Wayne-Dalton dealer. To find your local Wayne-Dalton dealer, refer to your
local yellow pages/business listings or go to the Find a Dealer section online at www.wayne-dalton.com
JAMB BRACKET SCHEDULE
1ST SET 2ND SET
JAMB BKT POSITION JAMB BKT POSITION
QIJB - 5 MIDDLE QIJB - 6 BOTTOM
QIJB - 3 BOTTOM QIJB - 6
QIJB - 3 BOTTOM QIJB - 6
QIJB - 3 BOTTOM QIJB - 7
QIJB - 3 BOTTOM QIJB - 5 BOTTOM
QIJB - 3 BOTTOM QIJB - 5 BOTTOM
QIJB - 3 BOTTOM QIJB - 5 BOTTOM
QIJB - 3 MIDDLE QIJB - 6
QIJB - 3 BOTTOM QIJB - 7
Drums
®
counterbalance drums
LEFT SIDE SHOWN
TWISTLOCK TAB
3RD SET
JAMB BKT POSITION
NOT APPLICABLE
MIDDLE NOT APPLICABLE
MIDDLE NOT APPLICABLE
TOP
HOLE
TOP NOT APPLICABLE
QIJB - 6 BOTTOM
MIDDLE
HOLE
QIJB - 6 BOTTOM
QIJB - 6 BOTTOM
BOTTOM
TOP QIJB - 7 MIDDLE
HOLE
TOP QIJB - 8 TOP
QUICK INSTALL FEATURE
LEFT HAND TORQUEMASTER ®
COUNTERBALANCE DRUM
BOTTOM
SECTION
COUNTERBALANCE
CABLE
MILFORD PIN
ASTRAGAL
RIGHT SIDE SHOWN
3RD SET HOLES
2ND SET HOLES
QI JAMB BRACKET
1ST SET HOLES
#1 END HINGE
(HINGE TUBE)
BOTTOM
SECTION
ROLLERS
BOTTOM BRACKET
BOTTOM
SECTION
13