Superwinch C-Serie Manual De Instalación, Operación E Mantenimiento página 8

I N S T A L L A T I O N
LOCATION
Mount the winch to a firm base.
The structure the winch is attached
to must be capable of withstanding
a load greater than 1-1/2 times the
winch's rated line pull.
The winch can be mounted in a
horizontal or vertical position. Do
not mount the winch where there
would be the possibility of it being
submerged in water. The winch is
weather resistant but not waterproof.
with the pull in the underwind direc-
tion. Improper mounting could dam-
age your winch, cause the brake to
not work and void your warranty.
Step (1)
Install structural support for winch.
See "Dimensions" section for winch
dimensions.
Step (2)
Mount the winch to the mount that
you have designed.
Mounting bolts supplied are the
correct length for use with a 1/4"
(6.3mm) thick mounting plate.
Electrical Schematic
REVERSAL SWITCH
(Switch may be in
Either Position)
Green
4
3
1
Load
Line
White
NC
OFF
Figure 2
This winch MUST
be mounted
Black
Green
Trigger
Switch
NC
NC
Winch
Motor
with strength weaker than
grade 5.
When attaching wire to the motor
terminals and solenoids (relays),
hold the inner nut when tightening
the outer nut. Do not allow the ter-
minals to rotate. It may cause inter-
nal wire breakage or part misalign-
ment. Be especially careful in pre-
venting the solenoid (relay) termi-
nals from rotating. Any rotation can
damage the solenoid (See Figure 1).
Figure 1
Step (3)
Disconnect the battery leads.
which are flammable and explosive.
Wear eye protection during installa-
tion and remove all metal jewelry.
Do not lean over battery while
making connections.
Step (4) Model 03003
Select a convenient location for
mounting the Solenoid Remote
Control Assembly. The solenoid
REVERSAL SWITCH
(Rope-In position)
Black
4
3
1
Load
Trigger
Line
Switch
White
NC
Winch
Motor
WIRE ROPE IN
Do not substi-
tute any bolt
Batteries con-
tain gases
REVERSAL SWITCH
(Rope-Out position)
Green
4
3
1
Load
Trigger
Line
Switch
White
NC NC
Winch
Motor
WIRE ROPE OUT
Black
7
7