Rock Shox SID Race Manual Del Usuario página 5

Maintenance • Service
Maintenance
To maintain high performance, safety, and long life, periodic maintenance is required. Performing maintenance
more often is necessary if you ride in extreme conditions.
T T
ORQUE IGHTENING
Brake Posts
Top Cap Assemblies
Air Shaft Nut
Cartridge/Sleeve Retainers
Crown Bolts
B
EFORE
C :
HECK THE FOLLOWING
1. Front wheel and quick release for proper installation and adjustment.
2. Fork for any obvious damage (crown, brace, upper tubes, lower tubes, and dropouts).
3. Front brake cable for proper routing.
4. Front brake pads for proper contact with the rim.
5. Front brake lever for proper adjustment.
6. Headset for proper function and adjustment.
7. Clean and dry the fork.
A
FTER EIGHT HOURS OF RIDING
1. Wipe exterior surfaces, XXX-seal area, and upper tubes.
2. Using a small blade screwdriver, carefully push the dust wipers up from the lower tubes. To prevent scratching
the upper tubes, cover the screwdriver tip with a soft cloth.
3. Using the tip of the screwdriver, carefully lift up the foam lubrication ring. Insure that the foam ring is clean
and free of debris. Apply 2-3 drops of RockShox oil to the foam ring.
4. Refit the foam lubrication ring into the lower tube area.
5. Push the dust wipers down onto the lower tube assembly.
6. Check the top cap assemblies and brake posts for proper torque using the above values.
Service
SID forks should be fully serviced every 50 riding hours by a qualified technician with proper tools. Fore and aft
movement between the upper and lower tube assembly indicates that the bushings have worn and should be
replaced. Please contact your local RockShox dealer or the nearest distributor in the International Distributor List,
which is located in the back of this manual. Read the warranty for further warranty repair and contact
information.
Page 8
S
PECIFICATIONS
60 in-lb. (6.8 Nm)
45 in-lb. (5.1 Nm)
45 in-lb. (5.1 Nm)
20 in-lb. (2.4 Nm)
90 in-lb. (10.2 Nm)
E R
VERY IDE
PN 950-004512-00, Rev. A
Warranty
R S , I .
OCK HOX NC WARRANTS ITS PRODUCTS FOR A PERIOD OF ONE YEAR FROM ORIGINAL DATE OF PURCHASE TO BE FREE FROM
. A R S
DEFECTS IN MATERIALS OR WORKMANSHIP NY OCK HOX PRODUCT THAT IS RETURNED TO THE FACTORY AND IS FOUND BY
R S
OCK HOX TO BE DEFECTIVE IN MATERIALS OR WORKMANSHIP WILL BE REPAIRED OR REPLACED AT THE OPTION OF
T . R
HIS WARRANTY IS THE SOLE AND EXCLUSIVE REMEDY OCK
.
CONSEQUENTIAL DAMAGES
T
HE WARRANTY DOES NOT APPLY TO PRODUCTS WHICH HAVE NOT BEEN PROPERLY INSTALLED AND ADJUSTED ACCORDING TO
. T
INSTALLATION INSTRUCTIONS HE WARRANTY DOES NOT COVER ANY PRODUCT THAT HAS BEEN SUBJECT TO MISUSE OR WHOSE SERIAL
, . T
NUMBER HAS BEEN ALTERED DEFACED OR REMOVED HIS WARRANTY DOES NOT COVER PAINT DAMAGE OR MODIFICATIONS TO THE
. P .
PRODUCT ROOF OF PURCHASE IS REQUIRED
Warranty Repair
If for any reason it should be necessary to have warranty work done, return the product to the place of purchase.
In the USA, Dealers should call for a Return Authorization number (RA#) prior to returning product.
Products returned for inspection must be sent freight prepaid and with proof of purchase to:
R R o o c c k k S S h h o o x x , , I I n n c c . .
4 4 0 0 1 1 C C h h a a r r c c o o t t A A v v e e . .
S S a a n n J J o o s s e e , , C C A A 9 9 5 5 1 1 3 3 1 1
For more technical information, visit our website at www.rockshox.com
Toll-free Technical Support in the USA, call 1.800.677.7177
Customers in countries other than the USA should contact their local dealer or distributor.
IMBA Rules of the Trail
• Ride on open trails only
• Leave no trace
• Control your bicycle
• Always yield trail
• Never spook animals
• Plan ahead
PN 950-004512-00, Rev. A
R S
OCK HOX
S ,
HOX SHALL NOT BE HELD LIABLE FOR ANY INDIRECT SPECIAL
R
Page 9
English
, I .
NC
,
OR
S
OCK HOX