THERMOBILE IMAC 1200 Manual Del Usuario página 18

English
5 MAINTENANCE
5.1 Maintenance table
After each winter season, register any
maintenance carried out in the table at the back of
this manual.
Description
Check the pump for leakage, corrosion and dirt.
Check the general condition of the pump, fans, ignition, photocell, burner, electrical
installation, combustion room, and heat exchanger.
Check the fuel lines for blockages, corrosion and leakage.
Check the fan of the burner for corrosion and dirt.
Check the fan for corrosion and dirt.
Clean the filters of the pump and the magnet valve.
Check the photocell for signs of damage. Make sure the photocell is free from dust and
deposit.
Check the settings of the electrodes.
Check the nozzle for dust, etc.
Clean the fuel filter with turpentine.
Clean the heat exchanger.
Clean the inlet/outlet.
Check the torque of the armatures. The torque value should be 60 Nm.
Hot
Do not touch the flue and air outlet!
Wait until the flue and the air outlet have
cooled down sufficiently before carrying
out any maintenance.
5.2 General
Warning
Switch off the power supply before
carrying out any repairs!
If the convector heater is to be stored for a longer
period of time:
1. Switch on the convector heater for three
minutes. This will protect the pump against
corrosion.
2. Make sure the burner head is free from dust
and deposit.
A dirty heater head will cause insufficient
combustion, resulting in the development of
soot and carbon monoxide and causing
damage to the burner room.
3. Close the valve of the fuel supply.
4. Remove the electrical plug.
18
18
/i
5.3
Check the photocell:
1.
2.
3.
4.
Reinstall the photocell in reverse order.
40.021.086 - rev 01 - 2019
40.20.927 - rev. 06 - 2011
Photocell (Fig. 9)
Open the doors to the burner compartment.
Remove the cover of the burner.
Remove photocell (A) from plate (B).
Clean the photocell if the glass has turned
black.
If the glass is cracked, the photocell must be
replaced by the dealer.
IMAC 1200/1500/2000EC
ENGLISH
Period
Yearly
User
Dealer
User
User
User
Dealer
User
Dealer
Dealer
User
Dealer
User
User
IMAC 2000 S