Costway TQ10198 Instrucciones De Montaje página 8

Problem Possible Cause
Undercharged
battery
Battery needs
Vehicle is
charging
sluggish
Old battery will not
accept a full charge
Vehicle is overloaded
Driving conditions
are too stressful
Intermittent Loose wire or
vehicle connector
operation
Motor or electrical
switch damage
When the Loose wire or
accelerator is connector
pressed, the
vehicle won't
run without a "Dead Spot on motor
push
Motor gear
box makes a
Broken gears
loud grinding
or clacking
noise
Charger get
This is normal and
warm during
should not be concern
use
14
Solution
A new battery should have been charged
for at least 12hours before using the
vehicle for the first time. After that, it must
be recharge the battery for at least 8-10
hours after each use. Never charge longer
than 24 hours. Check all connectors;
make sure the charger is plugged into the
wall. Make sure the power flow to the
outlet is on.
Be sure to charge the battery after each
use.
Even with proper care, a rechargeable
battery does not last forever. Average
battery life is 1 to 3 years depending on
vehicle use and use conditions. Replace
the battery with a new rechargeable
battery. Do not substitute parts. To get a
replacement battery, please contact
Service Center.
Allow no more than 1 rider at a time, follow
the 25kg (55lbs) weight capacity and don't
tow anything behind the vehicle.
Use only on a generally level ground.
Check all wires around the motors and all
connectors to make sure they are tight.
Contact your Service Center for diagnosis
and repair.
Check all wires around the motors and all
connectors to make sure they are tight.
Contact your Service Center for diagnosis
and repair.
Contact your Service Center for diagnosis
and repair.
No action required.
Battery makes
Some noise and
gurgling or
swelling is normal and
sizzling noise
should not be a
while charging
concern
11
1
2
3
4
5
Note: Some parts shown are assembled to both sides of the vehicle.
No. Part Quantity
1. Front components
2. Main Body
3. Omni-directional wheel
4. Bottom fender
5. Bumper bar
6. Rear Axle
No action required. lf the battery does not
make noise while charging. It does not
mean it is not accepting the charging.
10
9
7
6
No. Part Quantity
7. Gear Box
1
8. Rear Wheel
1
2 9. Rear Window
1 10. Lazyback
11. Seat
1
1
8
2
2
1
1
1
15