Emerson AVENTICS Sentronic 625 Instrucciones De Montaje página 25

Air is audibly escaping
Possible cause Remedy
Seal at the input connection, Check the seal and exchange if necessary.
output connection or exhaust
air connection is missing or
damaged.
Pressure regulator is not leak- Exchange the pressure regulator.
tight.
14 Technical data
This section contains an excerpt of the most important technical data. Further
technical data can be found on the product page in the Emerson store.
General
Specifications
Dimensions and weight See the product page in the Emerson store
Control Directly controlled valve
Housing material Aluminum / brass / stainless steel (depending on the version)
Material of internal parts Brass, stainless steel
Seals Nitrile (NBR), fluorocarbon rubber (FPM), EPDM
Ambient temperature dur- 0 ... 60 °C
ing operation
(min. ... max.)
Performance data
Specifications
3
Ø nominal width DN
[mm]
1)
Flow K value 0.18
V
3
[Nm /h]
At 6 bar 210
[std.l/min]
Degree of protection
1)
Test conditions in accordance with ISO 8778: Temperature: 20 °C, relative input pressure:
6 bar, relative output pressure: 5 bar
Assembly
Specifications
Mounting type Screw mounting
Mounting orientation Any, preferably vertical with solenoid upwards
Connections No hemp, no teflon strip
Electrics
Specifications
3
Ø nominal width DN
[mm]
Supply voltage (con-
trolled)
Max. residual ripple
Max. power consumption 12
[W] determined at room
temperature
Max. current consumption 500
[mA]
Electrical connection Depending on your configuration:
• 5-pin electrical connector M12 or
• 7-pin electrical connector M16
Input / outputs
Set point input 0 ... 10 V (input resistance 140 kΩ)
0 ... 20 mA / 4 ... 20 mA (input resistance 250 Ω)
Actual value output 0 ... 10 V (max. 10 mA), short-circuit-resistant
0 ... 20 mA / 4 ... 20 mA (max. 24 V DC)
Digital output PNP; open collector; max. 200 mA / 4.8 W, short-circuit-resis-
tant
HIGH (24 V DC) for actual = set point
LOW (open) for actual ≠ set point
Standards and directives complied with
See declaration of conformity.
AVENTICS™ Sentronic 625 | IM502079-014-R01 | English
6 12 20
0.60 1.20 4.80
700 1400 5600
IP65
6 12 20
24 V DC
10 %
24 34 44
1000 1400 1800
Pneumatics
Specifications
Medium • Air or neutral gas
• ISO 8573-1:2010 [7:4:4]
• Non-condensing
Connections 1/8 – 1/4 – 1/2 – 1 – G/NPT
Max. input pressure Depending on the product variant.
the material
Medium temperature 5 °C ... 60 °C
(min. ... max.)
Hysteresis < 1 % of the final value
Linearity < 0.5 % of the final value
Reproducibility < 0.5 % of the final value
Min. set point 50 mV (0.1 mA / 4.08 mA) with shut-off function
Min. output pressure 1 % of the final value
15 Accessories
Information on accessories can be found on the product page in the Emerson
store.
15.1 Accessories for Europe/Asia
Description
M12 electrical connector, straight, 5-pin, with screw terminals
M12 electrical connector, angled, 5-pin, with screw terminals
Power supply cable M12 2 m, 5 x 0.25 mm², straight electrical connec-
tor
Power supply cable M12 2 m, 5 x 0.25 mm², angled electrical connec-
tor
Power supply cable M12 5 m, 6 x 0.56 mm², straight electrical connec-
tor
Power supply cable M12 5 m, 6 x 0.56 mm², angled electrical connec-
tor
Power supply cable M12 10 m, 6 x 0.56 mm², straight electrical con-
nector
Power supply cable M12 10 m, 6 x 0.56 mm², angled electrical connec-
tor
Power supply cable 5 m, 8 x 0.5 mm², straight electrical connector
Power supply cable 10 m, 8 x 0.5 mm², straight electrical connector
Power supply cable 10 m, 8 x 0.5 mm², angled electrical connector
Parameterization adapter RJ45 Ethernet TCP/IP, 0.4 m cable
15.2 Accessories for America
Description
M12 electrical connector, straight, 5-pin, straight, 12 mm
Cable fitting PG9
M12 electrical connector, angled, 5-pin, 90°, 12 mm
Cable fitting PG9
Power supply cable, 6-wire, straight electrical connec-
tor, 5-pin M12, 24 AWG, screened
Power supply cable, 6-wire, angled electrical connector,
5-pin M12, 24 AWG, screened
Power supply cable 8 x 0.5 mm², straight electrical con-
nector
Power supply cable 10 m, 8 x 0.5 mm², angled electrical connector
Parameterization adapter RJ45 Ethernet TCP/IP, 0.4 m cable
See g 5.2.1 Configuration of
number.
88100256
88100725
88100726
88100727
88100728
88100729
88100730
88100731
N43802302700000
N43802302800000
N43802302900000
N52480010000000
Item no.
TC05F20000000000
TC05F20000000000
3 m TC0503MMS000671Y
5 m TC0505MMS000671Y
3 m TD0503MMS000671Y
5 m TD0505MMS000671Y
5 m N43802302700000
10 m N43802302800000
N43802302900000
N52480010000000
Item no.
25