Preventative Maintenance; Machine Storage - Clarke CA90 32T Instrucciones De Uso

A - ENGLISH
PREVENTITIVE MAINTENANCE
WARNING !
Before performing any maintenance on the machine, be sure that
the power is turned off, or the batteries disconnected.
Repairs are to be completed by an authorized Clarke service
center only. Any repairs completed by unauthorized persons will
void the warranty.
DAILY MAINTENANCE
1. Remove pad driver / brush and clean with approved cleaner.
2. Drain recovery and solution tanks completely and rinse out with
clean water. Visually check the recovery tank for debris and clean
out as necessary.
3. Raise squeegee assembly off the fl oor and wipe it down with a
damp towel. Be sure to store the squeegee in the up position.
4. Remove the fl oat shut-off assembly and rinse it out with clean
water.
5. Clean machine with an approved cleaner and a damp towel.
6. Recharge batteries.
WEEKLY MAINTENANCE
1. Check fl uid level in batteries.
2. Check batteries for loose or corroded cables.
3. Keep battery tops clean from corrosion.
MONTHLY MAINTENANCE
1. Check machine for leaks and lose fasteners.
2. Lubricate all grease points and pivot points with silicon spray and
approved grease.
3. Place machine over a fl oor drain. Flush solution system by pouring
3 gallons of hot water and approved alkaline detergent into the
solution tank and running machine (with solution control on) for 45
seconds. Turn machine off and let it sit over-night. The following
day, drain the remaining solution and rinse the solution tank out
with clean water.
A - 8
INSTRUCTIONS FOR USE
CA90 32T - 56091127
VACUUM MOTOR MAINTENANCE
1. Contact your local Clarke Distributor for any motor maintenance.
2. Vacuum motor should have the brushes checked every 250 hours.
Brushes should be replaced when they are worn to a length of
10mm or less.
BATTERY MAINTENANCE
HINT: For the best machine performance, keep batteries charged
at all times. Do not let them sit in a discharged condition.
WARNING !
Batteries are dangerous! Batteries emit hydrogen gas and an
explosion or fi re can result. Keep sparks and fi re away from
batteries at all time.
Whenever servicing batteries, be sure to wear protective gloves.
Avoid contact with battery acid at all times!
1. Always follow the battery charging directions as outlined in the
BATTERY CHARGING section of this manual.
2. Keep battery tops and terminals free from corrosion. A strong
solution of baking soda and water is the best way to keep the
batteries corrosion free. DO NOT ALLOW THE BAKING SODA /
WATER SOLUTION TO ENTER THE BATTERY CELLS.
3. Use a wire brush with the baking soda solution to properly clean
the battery posts and connections.
4. Check battery connections for wear and loose terminals. Replace if
necessary.

MACHINE STORAGE

1. Always store the machine indoors.
2. Always store the machine in a dry area.
3. Always store the machine with pads brushes removed.
4. Always store the machine with the squeegee assembly in up
position.
5. If storing in an area which may reach freezing temperatures, be
sure to drain all fl uids from the machine prior to storage. Any
damage caused by freezing temperatures will not be covered by
the warranty. Remove VF82168-2 solution fi lter cover to drain all
fl uid form hoses.
6. Drain the recovery tank and remove the clear lid on the top of the
recovery tank so that it can "breathe" during storage.
7. Drain the solution tank of all fl uid.
7/2014