Publicidad
Observing the following statements and warnings reduces the likelihood of serious or fatal injury
Installation Safety – Have You:
‰ ‰
Consulted‰the‰assembly‰instructions‰supplied‰with‰your‰particular‰model?
‰ ‰
Noted‰this‰accessory‰is‰to‰be‰used‰only‰on‰approved‰designs?‰(Do‰not‰alter‰its‰design‰or‰add/remove‰components.)
‰ ‰
Made‰sure‰all‰hardware‰is‰tightened‰securely?‰(Supplied‰bolt‰covers‰must‰also‰be‰fastened‰securely.)
‰ ‰
Using‰a‰hacksaw,‰cut‰off‰all‰protruding‰threaded‰ends‰of‰bolts‰and‰other‰fasteners‰and‰remove‰any‰sharp‰edges‰with‰a‰metal‰file‰as‰needed,‰and‰coated‰fastener‰ends‰with‰lead‰free‰paint?
‰ ‰
Placed‰the‰equipment‰on‰level‰ground,‰not‰less‰than‰six‰feet‰(1.8‰meters)‰from‰any‰structure‰or‰obstruction‰such‰as‰a‰fence,‰garage,‰house,‰overhanging‰branches,‰laundry‰lines,‰or‰electrical‰wires?
‰ ‰
Made‰sure‰home‰playground‰equipment‰is‰not‰installed‰over‰concrete,‰asphalt,‰packed‰earth‰or‰any‰other‰hard‰surface?‰(A‰fall‰onto‰a‰hard‰surface‰can‰result‰in‰serious‰injury‰to‰the‰equipment‰user.)
‰ ‰
Verified‰that‰suspended‰climbing‰ropes,‰chain,‰or‰cable‰are‰securely‰anchored‰at‰both‰ends‰and‰cannot‰be‰looped‰back‰upon‰itself?
‰ ‰
Consulted‰in‰assembly‰instructions‰of‰your‰particular‰model‰for‰minimum‰use‰zones?
‰ ‰
Used‰a‰water‰sealant‰on‰your‰play‰set‰to‰protect‰the‰wood‰and‰prevent‰cracking‰and‰warping?
‰ ‰
Followed‰all‰anchoring‰and‰shock‰absorbing‰surfacing‰requirements‰below‰as‰they‰apply?
‰ ‰
Made‰sure‰not‰to‰allow‰children‰to‰use‰equipment‰until‰it‰is‰properly‰installed?
‰ ‰
Made‰sure‰to‰adjust‰all‰swings‰so‰there‰is‰a‰minimum‰8''‰clearance‰between‰the‰swing‰and‰the‰ground‰surface?
Operating Safety – Have You:
‰ ‰
Determined‰that‰on-site‰adult‰supervision‰is‰provided‰for‰children‰of‰all‰ages?
‰ ‰
Warned‰children‰of‰the‰following‰before‰allowing‰them‰to‰use‰the‰equipment?
‰ ‰
Not‰to‰walk‰close‰to,‰in‰front‰of,‰behind‰or‰between‰moving‰items.
‰ ‰
Not‰to‰twist‰swing‰or‰any‰other‰accessory‰chains‰or‰ropes‰or‰loop‰them‰over‰the‰top‰support‰bar‰since‰this‰will‰reduce‰the‰strength‰of‰chain‰or‰rope.
‰ ‰
Not‰to‰swing‰empty‰seats‰or‰other‰accessories.
‰ ‰
Not‰to‰slide‰down‰swing‰chains.
‰ ‰
Be‰sure‰to‰sit‰in‰the‰center‰of‰the‰swing‰seat‰and‰other‰accessories‰with‰full‰weight‰on‰the‰seat.
‰ ‰
Not‰to‰attach‰items‰to‰the‰playground‰equipment‰that‰are‰not‰specifically‰designed‰for‰use‰with‰the‰equipment‰such‰as‰but‰not‰limited‰to,‰jump‰ropes,‰clotheslines,‰pet‰leashes,‰cables‰and‰chain.‰
They‰may‰cause‰a‰strangulation‰hazard.
‰ ‰
Not‰to‰climb‰or‰walk‰on‰the‰top‰of‰swing‰beams,‰railings‰or‰roof.
‰ ‰
Not‰to‰use‰equipment‰in‰a‰manner‰other‰than‰intended.
‰ ‰
Not‰to‰get‰off‰equipment‰while‰it‰is‰in‰motion.
‰ ‰
Not‰to‰climb‰on‰the‰equipment‰when‰it‰is‰wet.
‰ ‰
Be‰sure‰to‰go‰down‰slides‰feet‰first.
‰ ‰
Determined‰that‰only‰one‰child‰per‰planned‰occupant‰seat‰should‰be‰allowed‰on‰this‰set‰at‰one‰time.
‰ ‰
Determined‰children‰must‰be‰dressed‰appropriately‰for‰play.‰Avoid‰hooded‰jackets,‰bicycle‰or‰other‰sports‰helmets,‰clothing‰with‰draw‰strings‰and‰loose‰fitting‰clothes‰which‰could‰become‰
entangled‰or‰snagged‰on‰equipment.
‰ ‰
Determined‰that‰suspended‰climbing‰ropes,‰chain,‰or‰cable‰are‰securely‰anchored‰at‰both‰ends‰and‰cannot‰be‰looped‰back‰upon‰itself.
‰ ‰
Made‰certain‰the‰slide‰is‰placed‰so‰that‰is‰is‰not‰in‰direct‰sunlight.
Safety Maintenance – Follow these preventive maintenance instructions at the intervals required:
‰ ‰
To‰prevent‰the‰deterioration‰of‰materials,‰remove‰plastic‰swing‰seats‰and‰other‰plastic‰accessories‰when‰outdoor‰temperature‰dips‰down‰to‰or‰below‰32°‰F‰and‰take‰indoors.‰Reinstall‰these‰plastic‰
elements‰at‰the‰beginning‰of‰each‰play‰season.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰check‰metal‰parts‰for‰rust.‰If‰found,‰sand‰and‰repaint‰using‰a‰non‰lead-based‰paint‰meeting‰the‰requirements‰of‰16‰CFR‰1303‰or‰SOR/2005-109.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰and‰once‰a‰month‰during‰each‰play‰season,‰check‰all‰moving‰parts‰for‰wear,‰rust‰or‰other‰deterioration.‰Replace‰as‰needed.‰If‰any‰of‰these‰conditions‰exist,‰call‰
1-800-888-1232‰to‰order‰replacement‰accessories.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰and‰once‰a‰month‰during‰each‰play‰season‰lubricate‰metallic‰moving‰parts.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰and‰twice‰a‰month‰during‰each‰play‰season,‰check‰all‰protective‰coverings‰on‰bolts,‰pipes,‰edges,‰and‰corners.‰Replace‰if‰they‰are‰loose,‰cracked,‰or‰missing.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰and‰twice‰a‰month‰during‰each‰play‰season,‰rake‰and‰check‰depth‰of‰loose‰fill‰protective‰surfacing‰material‰to‰prevent‰compaction‰and‰maintain‰appropriate‰
depth.‰Replace‰as‰necessary.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰and‰twice‰a‰month‰during‰each‰play‰season‰tighten‰all‰hardware.
‰ ‰
At‰the‰beginning‰of‰each‰play‰season‰and‰twice‰a‰month‰during‰each‰play‰season,‰check‰all‰wood‰members‰for‰deterioration‰and‰splinters.
‰ ‰
Sand‰down‰splinters‰and‰replace‰deteriorating‰wood‰members.
Disposal Instructions
‰ ‰
When‰the‰equipment‰is‰taken‰out‰of‰service,‰it‰must‰be‰disassembled‰and‰disposed‰of‰in‰such‰a‰way‰that‰no‰unreasonable‰hazards‰will‰exist‰at‰the‰time‰the‰set‰is‰discarded.
This product is intended for single family home/residential use only and not intended for use in any public setting. Placement in public settings constitutes misuse of this product.
According‰to‰ASTM‰requirements,‰all‰kits‰must‰be‰anchored‰to‰the‰ground‰and,‰if‰the‰unit‰has‰a‰climbing‰rope,‰the‰rope‰end‰must‰be‰anchored.‰If‰soil‰conditions‰permit‰stakes‰to‰be‰pulled‰out‰easily,‰cementing‰into‰
ground‰is‰necessary.
To anchor the unit to the ground,‰Follow‰the‰instructions‰included‰in‰this‰plan‰for‰applying‰Anchor-It‰devices‰to‰your‰unit,‰or‰use‰2"‰x‰4"‰x‰18"‰(45mm‰x‰95mm‰x‰457mm)‰pressure-
‰
treated‰stakes.‰Pound‰stakes‰into‰ground‰at‰least‰12"‰(305mm)‰at‰all‰inside‰corners‰of‰the‰posts‰(including‰A-frame‰legs‰and‰climbing‰unit‰posts).‰Attach‰with‰four‰(4)‰3-1/2"‰screws‰
(approved‰for‰treated‰wood)‰per‰stake‰into‰each‰tower‰and/or‰A-frame‰upright.
‰
If the unit has a climbing rope,‰securely‰anchor‰the‰rope‰at‰both‰ends.
‰
Once the unit is completely assembled and before children are allowed to play on it,‰proper‰shock-absorbing‰surfacing‰material‰must‰be‰installed.‰This‰may‰be‰accomplished‰by‰
using‰loose-fill‰materials‰at‰a‰sufficient‰depth.‰The‰Consumer‰Product‰Safety‰Commission‰"Handbook‰for‰Public‰Playground‰Safety"‰lists‰the‰following‰materials‰and‰required‰depths‰
that‰are‰sufficient‰for‰home/residential‰application.‰Supplemental‰information‰may‰be‰found‰in‰ASTM‰F1292.‰For‰fall‰height‰protection‰up‰to‰9‰ft.‰(2.742m)‰(recommended‰for‰all‰kits):
‰
‰
‰
‰
‰
‰
‰
‰
‰
When‰properly‰installed,‰shock‰absorbing‰material‰will‰completely‰cover‰the‰horizontal‰baseboards‰on‰climbing‰units.‰This‰protective‰surfacing‰must‰extend‰a‰minimum‰of‰6‰ft.‰(1.828m)‰in‰all‰directions‰from‰the‰
perimeter‰of‰the‰equipment‰or‰from‰the‰outermost‰edges‰of‰any‰component.‰For‰example,‰a‰slide‰extending‰beyond‰the‰platform‰must‰have‰protective‰surfacing‰at‰least‰6‰ft.‰(1.828mm)‰out‰from‰both‰sides‰as‰well‰
as‰the‰end.‰For‰swings,‰the‰protective‰surface‰must‰extend‰at‰least‰14‰ft.‰(6m)‰out‰from‰both‰the‰back‰and‰front‰of‰the‰swing‰when‰the‰swing‰is‰in‰its‰rest‰position.
1
These‰depths‰were‰derived‰from‰the‰CPSC‰Handbook.‰has‰not‰done‰independent‰tests‰to‰determine‰these‰required‰depths.
Save this instruction sheet in the event the manufacturer needs to be contacted.
IMPORTANT! ADDITIONAL REQUIRED SAFETY INSTALLATION INSTRUCTIONS
LOOSE FILL MATERIAL REQUIRED
‰
Wood‰Mulch‰ ‰
‰
‰
Double‰Shredded‰Bark‰Mulch‰‰
‰
Uniform‰Wood‰Chips‰‰
‰
Safety Checklist for Play Sets and Accessories
1
(UNCOMPRESSED) DEPTH
in. (mm)
9"‰(229mm)
9"‰(229mm)
12"‰(305mm)
2
Play sets and accessories
designed for children,
ages 3 to 10 years, unless
otherwise specified
Publicidad
