Safety Instructions; Technical Data - Metal Works CAT 755 Manual

1 Safety instructions

To avoid personal injury or property damage during system operation, read and follow all cautions, warnings
and instructions, included with or attached to each product.
Supplier cannot be responsible for damage or injury resulting from unsafe use of product, lack of
maintenance or incorrect product and system application.
1. The maximum load capacity is 0.5 ton. Do not exceed this rated capacity.
2. This jack is used as an aid in the removal and installation of a transmission or a differential as individual
components. Do not use it for any other purpose it is not designed to perform.
3. Do not use this transmission jack as a vehicle lifting device or as a vehicle support.
4. Keep children and unauthorized persons away from the work area.
5. Remove loose clothing. Remove ties, watches, rings and other loose jewellery, and contain long hair.
6. Always wear ANSI approved safety goggles when operating this jack.
7. Keep proper balance and footing, do not overreach and wear nonskid footwear.
8. Only use this equipment on a surface that is stable, level, smooth and capable of sustaining the load.
Keep the surface clean, tidy and free from unrelated materials and ensure that there is adequate lighting.
9. Inspect the jack before each use. Do not use if bent, broken, cracked, leaking or otherwise damaged ,
any suspect parts are noted or it has been subjected to a shock load.
10. Vehicle must be properly and adequately supported before starting repairs.
11. Do not use this jack to lift or support assemblies such as a differential with axle, or a transmission with
bell housing which will be bulky and difficult to balance, and may cause the jack to tip over and lead to
property damage and/or serious personal injury.
12. Center load on the saddle and be sure the setup is stable and secure.
13. Never move this jack with a load any higher off ground than necessary and move it slowly and carefully.
14. Transfer load immediately to appropriate support device for service or repair.
15. Do not operate this jack when you are tired or under the influence of alcohol, drugs or any intoxicating
medication.
16. Do not allow untrained persons to operate this product and do not make any modifications to this
product.
17. Do not expose the equipment to rain or snow.
18. Use a qualified person to maintain the equipment in good condition. Keep it clean for best and safest
performance.
19. If the equipment need repairing and/or there are any parts that need to be replaced, have it repaired by
authorized technicians and only use the replacement parts supplied by the manufacturer.
WARNING! The warnings, cautions and instructions discussed in this instruction
manual cannot cover all possible conditions and situations that may occur. It must
be understood by the operator that common sense and caution are factors which
cannot be built into this product, but must be supplied by the operator.

2 Technical data

Capacity:
Minimum height:
Maximum height:
Dimensions:
Weight:
Spare parts: see pages 14-15
8
®
500 kg
1075 mm
1890 mm
570 x 570 x 1100 mm
32 kg
CAT755 - NLFRENES - v1.1 - 10102013
EN