Troubleshooting Chart - World Dryer AirStyle B Serie Instructions

Troubleshooting Chart

Symptom Model
Dryer fails to start All
All
Dryer runs continuous All
and will not shut-off.
Dryer blows cold air. All
Dryer air too hot. All
Dryer noisy or vibrates. All
Limited Warranty
WORLD DRYER LIMITED TEN – YEAR WARRANTY. World Warm Air Hair Dryer, Model covered in this manual, is warranted by World Dryer Corporation to the
original user against defects in workmanship or materials under normal use for 10 years after date of purchase. Any part which is determined to be defective in material or
workmanship and returned to an authorized service location, as World designates, shipping costs prepaid, will be, as the exclusive remedy, repaired or replaced at World's
LIMITATION OF LIABILITY. To the extent allowable under applicable law, World's liability for consequential and incidental damages is expressly disclaimed. World's
liability in all events is limited to and shall not exceed the purchase price paid.
WARRANTY DISCLAIMER. World has made a diligent effort to provide product information and illustrate the products in this literature accurately; however, such infor-
PURPOSE, or that the products will necessary conform to the illustrations or descriptions. Except as provided below
other than as stated in the "LIMITED WARRANTY" above is made or authorized by World.
PRODUCT SUITABILITY. Many jurisdictions have codes and regulations governing sales, construction, installation, and/or use of products for certain purposes, which
may vary from those in neighboring areas. While World attempts to assure that the products comply with such codes, it cannot guarantee compliance, and cannot be respon-
sible for how the product is installed or used. Before purchase and use of a product, review the product application, and all applicable national and local codes and regulations,
and be sure that the product, installation, and use will comply with them.
Certain aspects of disclaimers are not applicable to consumer products; e.g., (a) some jurisdictions do not allow the exclusion or limitation of incidental or consequential dam-
ages, so the above limitation or exclusion may not apply to you; (b) also, some jurisdictions do not allow a limitation on how long an implied warranty lasts, consequentially
purpose applicable to consumer products purchased by consumers, may not be excluded or otherwise disclaimed.
Manufactured by World Dryer Corporation, Berkeley, Illinois 60163 U.S.A.
PROMPT DISPOSITION. World will make a good faith effort for prompt correction or other adjustment with respect to any product which proves to be defective within
directions. If unable to resolve satisfactorily, write to World, giving dealer's name, address, date, and number of dealer's invoice, and describing the nature of defect. Title and
Possible Cause(s) Corrective Action
No power to the unit Check if power is "ON"
Check electrical connections.
Faulty Timer / Switch With Dryer Cover Removed, depress the Timer Switch Blade;
a. Timer Motor should turn.
b. With an Ohm Meter, check for continuity across the Switch Terminals.
Faulty Motor "No" in either test, replace Timer Assembly;
"Yes" in both tests, replace Motor.
Faulty Timer With Dryer Cover Removed, depress the Timer Switch Blade;
Timer Motor should turn. "No" replace Timer Assembly.
Defective Heating Element 1. Check for break in Element Wire.
Or Defective Thermostat 2. Check Heating Element and Thermostat for continuity. If open, replace as necessary.
Machine is dirty 1. Inspect for foreign material. Using a soft brush and vacuum, clean fan and motor.
2. Replace motor if running slow or erratic.
Fan not centered in housing 1. Fan may be rubbing against edge of Fan Housing. To center Fan;
a. On plastic fan unit, carefully "tap" the Fan Hub with a screw driver & small hammer
b. On metal fans, loosen the set screw and adjust the fan until it turns freely.
■ Foreign object in Fan. 1. Inspect for foreign material. Using a soft brush and vacuum, clean fan and motor.
■ Broken or bent Fan. 1. Replace Fan.
■ Bent Motor shaft. 1. Replace Motor.
to center it until the Fan turns freely.
10
ABLE, or FIT FOR A PARTICULAR