Bayco 450 Serie Instrucciones

Instructions for 450 Series Incandescent
Light on Retractable Reel
INS-450-12
Electrical Rating - All models use 125 Volts 60 HZ
CAUTION - TO REDUCE THE RISK OF ELECTRIC SHOCK AND FIRE - PULL PLUG
WHEN SERVICING, CONNECTING/DISCONNECTING FROM THE CORD REEL OR
WHEN RE-LAMPING - USE ONLY 75 WATT OR SMALLER BULB
CAUTION
DO NOT use this cord reel in explosive atmospheres, near flammable liquids, or where
explosion proof lamps are required.
DO NOT use in the proximity of vehicles or equipment when there is a risk of flammable
liquids coming into contact with the hand lamp
DO NOT immerse in water
DO NOT use in areas where water can accumulate or in rain or mist
CAUTION: Risk of Electric Shock – For Light Duty Dry Location Use Only
GENERAL USE CORD REEL ONLY. NOT FOR HARD USE. FOR INDOOR DRY
LOCATION USE ONLY FOR LIGHT DUTY RESIDENTIAL USE ONLY
WARNING: NOT FOR USE ABOVE HAZARDOUS LOCATIONS
CAUTION: DO NOT USE IN HAZARDOUS LOCATIONS AS REQUIRED BY THE
CANADIAN ELECTRICAL CODE, PART I
IMPORTANT SAFETY INSTRUCTIONS
This product has a 3 prong polarized plug on the power cord. Do not attempt to bypass
this safety feature by removing the round plug and defeat his safety feature. This plug will
fit into a grounded outlet only one way. If the plug does not fit fully into the outlet, contact
a qualified electrician. Never use with a two wire extension cord.
CAUTION: PULL OUT CORD TO FULL LENGTH WHEN USING RECEPTACLE
CAUTION: DO NOT ALLOW THE CORD TO RETRACT BY ITSELF AS DAMAGE OR
INJURY MAY OCCUR FROM EXCESSIVE REWIND SPEED
CAUTION: Drywall will not hold the weight of the reel assembly
CAUTION: Read and understand mounting instructions before attempting installation
and use of this product
Thank you for purchasing this Bayco cord reel. Please read these instructions before
using.
OPERATION

To operate, plug into a 120 Volt 60 HZ grounded outlet.

The work light has a push-push switch to turn the light on or off.

Pull out desired length of cord. Notice a clicking noise when pulling. Cord will stay at
the desired length during clicking and rewind after a pull past the clicking noise.
Extended length when retracted can be adjusted by sliding plastic ball to desired
position.
CAUTION: DO NOT ALLOW CORD TO RETRACT BY ITSELF, AS DAMAGE TO
CORD END FITTINGS MAY OCCUR FROM EXCESSIVE REWIND SPEED.
TO CLEAN OUTSIDE OF UNIT: Unplug the unit before cleaning and dry thoroughly
before re-using. Use a soft cloth with mild detergent. DO NOT use solvents such as
gasoline, turpentine, etc., to clean the unit. NEVER immerse the reel or cord end fittings
(receptacles or lamps) in water.
FEATURES

The cord is 20ft long; with polarized plug.

Metal shield holds 75 watt bulb maximum

7 amp circuit breaker

Mounts on ceiling or wall

Adjustable cord stop.
BULB REPLACEMENT

Disconnect the reel unit from electrical outlet

Open bulb cage and unscrew lamp from socket. Caution: bulb may be hot

Use a rough service lamp to Increase lamp life.

Install new lamp (maximum 75 Watts) and tighten finger tight only. Close lamp cage
door
BAYCO • 640 South Sanden Blvd. • Wylie, TX 75098 • 1-800-233-2155 • www.baycoproducts.com
MOUNTING
Ceiling or Wall Installation
1. Select a location within 2 feet of an electrical outlet. The outlet for a garage door
opener is desirable.
2. Drywall will not hold the weight of the reel assembly, so locate a ceiling joist or wall
stud and using the mounting bracket as a template, mark the holes so they are
centered on the ceiling joist or stud.
3. Attach the mounting bracket to the stud using the 2 wood screws provided.
4. Align the holes on the side of the reel with the holes in the side of the mounting
bracket and insert the pin.
5. Place the retaining ring on the pin and twist until the entire ring is through the hole in
the pin. DO NOT operate this reel without the retaining ring in place on the pin.
SAFETY / CARE
 Caution: do not allow the cord to retract by it self as damage or injury may occur from
excessive rewind speed.
 Adjust the cord stop to hold the receptacle at the desired length when the cord is
retracted.
 Before cleaning the reel always unplug from the power source.
 Clean the outside of the cord reel only. Use a soft cloth with mild detergent. Do not
use petroleum based to clean the cord reel. Never immerse the cord reel or
receptacles or work lights in water. Dry thoroughly before attempting to reattach to
power source.
WARRANTY
PRODUCTS COVERED UNDER THIS LIMITED WARRANTY:
This product is warranted to the original purchaser for 1 year and only covers failures due
to defects in materials or workmanship. If this product is used for rental purposes, the
warranty term is reduced to 90 days from the date of purchase.