NightStick XPR-5560GA Manual De Instrucciones

INSTRUCTION MANUAL
XPR-5560GA
THANK YOU FOR SELECTING THE NIGHTSTICK XPR-5560GA
INTRINSICALLY SAFE PERMISSIBLE RECHARGEABLE CAP LAMP!
PLEASE SAVE THESE INSTRUCTIONS
Please read these instructions before using your Nightstick XPR-5560GA
Intrinsically Safe Permissible Rechargeable Cap Lamp. They include
important safety information and operating instructions.
THE XPR-5560GA IS APPROVED FOR USE
Bayco Products, Inc.
Wylie, TX 75098
Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS
UL listed for use with Bayco Li-ion Battery Pack 5560-BATT
CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV1 GRPS E-G T135C
CLASS I ZONE 0 AEx ia IIC T4 Ga
CLASS I ZONE 0 Ex ia IIC T4 Ga
ID 4008947
I M1 Ex ia I Ma
INTRINSICALLY SAFE
II 1 G Ex ia IIC T4 Ga
SECURITE INTRINSEQUE
0359
WARNINGS - INTRINSICALLY SAFE
y Warning: To prevent ignition of a hazardous atmosphere, the XPR-
5560GA must only be charged in an area known to be non-hazardous.
y Warning: Use only the approved Nightstick 5500-BATT Lithium-ion
rechargeable battery pack.
y Warning: The approved Nightstick 5500-BATT Lithium-ion rechargeable
battery pack must be replaced by a qualified technician only.
y Warning: To prevent ignition of a hazardous atmosphere, do not open the
battery compartment or attempt to exchange the battery pack while in the
hazardous environment. This task must ONLY be performed in an area
known to be non-hazardous.
y Warning: Open the battery compartment on the XPR-5560GA and replace
the approved Nightstick 5500-BATT Lithium-ion rechargeable battery pack
in fresh air only.
y Warning: Substitution of components may impair intrinsic safety.
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
For personal safety, always confirm the rating of any known hazardous or
potentially hazardous location where the XPR-5560GA is to be used.
CAUTION
y Rechargeable Lithium-ion batteries must be used and charged properly.
Improper use can result in serious injury, fire, or death.
y Do not leave the battery in direct sunlight or use or store the battery inside
cars in hot weather.
y Do not expose the battery to water or salt water, or allow the battery to
get wet.
y Do not store the battery with metallic objects that may cause a short circuit.
y Immediately discontinue use of the battery if the battery emits an unusual
smell, feels hot, changes color, changes shape or appears abnormal in any
way.
y Keep out of the reach of children.
Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • USA • 1-800-233-2155 • 1-469-326-9400 • www.mynightstick.com
XPR-5560GA
Ex ia I Ma
Ex ia IIC T4 Ga
DEMKO YY ATEX YYYYX
IECEx UL YY.YYYYX
-20ºC ≤ Tamb ≤ +40ºC
3.7V/Cell Li-ion
INS-XPR5560GA_16
CHARGING THE LIGHT
WARNING: Use only the supplied Charger & approved Nightstick
Lithium-ion Rechargeable Battery Pack.
y The time required to charge the 5560 is conditional on the remaining
charge left in the Lithium-ion Rechargeable Battery Pack at the time of
charging. The maximum charge time required is approximately 6 hours.
y Fully charge the 5560 before the first use, or if the 5560 has been unused
for several months.
y When the 5560 is properly seated in the charger, the LED Charge Indicator
light will turn solid RED indicating that the Lithium-ion Rechargeable Battery
Pack is charging. The Lithium-ion Rechargeable Battery Pack is fully
charged when the LED Charge Indicator light turns GREEN.
y The Lithium-ion Rechargeable Battery Pack does not have any Recharge
Memory Effect; therefore placing the 5560 in the charger prior to full
depletion of the battery does not adversely affect the battery life. The 5560
can be kept in the charger indefinitely without any negative impact on the
battery or the battery life.
OPERATION
The XPR-5560GA is controlled by 2 Switches and has 5 separate lighting
modes:
y High-brightness Spotlight
y Low-brightness Spotlight
y High-brightness Floodlight
y Survival-mode Floodlight
y Dual-Light (both the Spotlight and Floodlight on at the same time)
Spotlight Modes
To activate the Spotlight, press and release the Spotlight Switch. The
default mode will be High-brightness. To select the Low-brightness Spotlight
mode, press the Spotlight Switch a second time within ¾ of a second of
the first press. If more that ¾ of a second has elapsed since pressing the
Spotlight Switch, the next press will turn the Spotlight off regardless of what
brightness mode the Spotlight is in.
Floodlight Modes
To activate the Floodlight, press and release the Floodlight Switch. The
default mode will be High-brightness. To select the Survival mode, press the
Floodlight Switch a second time within ¾ of a second of the first press. If
more that ¾ of a second has elapsed since pressing the Floodlight Switch,
the next press will turn the Floodlight off regardless of what brightness mode
the Floodlight is in.
Dual-Light Mode
Dual-Light mode allows the user to turn on both the Spotlight and the
Floodlight at the same time. Dual-Light mode can be activated by simply