Storage And Maintenance; Troubleshooting - Surtek CB50 Manual De Usuario Y Garantía

Battery size / rating
Motorcycle,
Small
garden
batteries
tractor, etc.
200 - 315 CCA
Car / trucks 315 - 550 CCA
550 - 875 CCA
Marine / deep cycle
AH Ampere Hours
NR Not Recommended
CCA Cold Cranking Amps
RC Reserve Capacity
MC Marine Capacity

STORAGE AND MAINTENANCE

• Battery charger should receive regularly maintenance and should be daily inspected.
• If an equipment damaged is detected contact with your deliver or with the manufacturer,
do not attempt to disassemble the charger.
• Disconnect the equip before performing any maintenance work.
• Clean the charger regularly with a cloth. After each use, clean the clamps to eliminate the
corrosion. Protect your skin against burns!

TROUBLESHOOTING

Problema
No meter Reading (AC cord
unplugged).
The charger does not turn on when
it is properly connected.A
Noise from charger (click).
2 A
6 -12 Ah 1,5 - 3
12- 32 Ah 3 - 8
40 - 60 RC 11-15
60 - 85 RC 15 -18
85 - 125 RC 18 -25
55 MC 15
80 MC 19
105 MC 23
Posible causa
Clips are not marking a good
connection.
Battery voltage is too low.
AC outlet is dead.
Poor electrical connection.
Circuit breaker is cycling.
Battery is defective.
Severely discharged battery but
otherwise a good battery.
Reverse connections at battery.
18
Charge rate / Charging time - hours
10 A 30 A 35 A
NR NR
2,5 -3 0,75-1 0,5 -0,75
3-4 1-1,5 0,75-1
4-5 1,5-1,7 1-1,5
4 NT
5 2 1,75
6 2,5
Rock clips back and forth for better
Plug in a lamp to check for voltage.
Check connections, rock back and
forth for a better connection.
May be in the wrong switch
Allow charging to continue until
battery has a chance to recover
sufficiently to take a charge. If
more than 20 min. stop charging
and have battery checked.
Shout off charger and correct lead
50 A 60 A
NR NR
NR
0,5-0,75 0,5-0,63
0,75-1 0,63-0,75
NR NR
NR
2 NR
Solución
connection.
Plug AC line into outlet.
position.
connections.
NR
NR
NR
NR
NR