Century Hearth FW240007 Manual De Instrucciones

This manual describes the installation and operation of the Model FW240007 non-catalytic wood
heater. This heater meets US Environmental Protection Agency's emission limits for wood heaters.
Under specific conditions this heater has been shown to deliver heat at rates ranging from 10,467 to
26,100 BTU per hour.
Model No. FW240007
This unit has been listed by Warnock Hersey
Limited to meet or exceed
ULC S-627 Canada and UL 1482 U.S.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
2ft(635mm) HIGHER THAN
3FT(1M) MIN NEAREST POINT OF
ROOF WITHIN 10ft(3M)
FROM ROOF
PENETRATION
MINIMUM OVERALL
G
HEIGHT FROM FLOOR
15FT(5M)
Unit must be placed on a noncombustible floor protection equivalent to 3/8" millboard.
Floor protector must have min. R value of .446
Consult your local building authorities for further information.
BE SURE TO INSTALL TWO
FULL BRICKS (S16040) IN
2 FULL BRICKS HANDLE
BAFFLE AS SHOWN
Twist spring handle
BAFFLE ASSEMBLY
clockwise motion while pushing on to handle;
spring handle will "thread" down to desired
location.
Desired Burn Setting
Low
Med / Low
Med / High
High
1 . M a x i m u m b u r n t i m e s a n d h e a t o u t p u t s a r e b a s e d o n l a b o r a t o r y t e s t i n g u s i n g f u l l l o a d s o f
s e a s o n e d h a r d w o o d s , a n d m a y v a r y i n i n d i v i d u a l u s e d e p e n d i n g o n h o w t h e s t o v e i s o p e r a t e d , t y p e a n d m o i s t u r e
c o n t e n t s o f f u e l , a n d o t h e r f a c t o r s . M a x i m u m b u r n t i m e s a r e a c h i e v e d u n d e r d i f f e r e n t o p e r a t i n g c o n d i t i o n s t h a n a r e
m a x i m u m h e a t o u t p u t s .
2 . T h e s e v a l u e s a r e b a s e d o n o p e r a t i o n i n b u i l d i n g c o d e - c o n f o r m i n g h o m e s u n d e r t y p i c a l W i n t e r c l i m a t e c o n d i t i o n s i n t h e
n o r t h e a s t e r n U . S . I f y o u r h o m e i s o f n o n s t a n d a r d c o n s t r u c t i o n ( e . g . U n u s u a l l y w e l l - i n s u l a t e d , b u i l t u n d e r g r o u n d , o r i f y o u
l i v e i n a m o r e t e m p e r a t e c l i m a t e ) , t h e s e m a y n o t a p p l y. S i n c e s o m a n y v a r i a b l e s a f f e c t p e r f o r m a n c e , c o n s u l t y o u r C F M
A u t h e r i z e d D e a l e r t o d e t e r m i n e r e a l i s t i c e x p e c t a t i o n s f o r y o u r h o m e .
3 . U n d e r s p e c i f i c c o n d i t i o n s u s e d d u r i n g E PA e m i s s i o n t e s t i n g .
NOTE: Retain this sheet for future reference
6" Flue Required
Figure A: Clearance from combustible constructions
A minimum clearance of 18" (457mm) to the chimney connector
may be required by the authority having jurisdiction.
From Heater From Chimney Connector
A Sidewall.......... 18" (457 mm) D Sidewall.................25-1/4" (648 mm)
B Backwall...............15" (381 mm) E Backwall................17-1/2" (445 mm)
C Corner....................7" (175 mm) F Corner....................15"
G Ceiling....................56"
BACK WALL
B
E
8"(203mm)
A
D
*16
**18
C
*16"(406mm) U.S.A.
**18"(457mm) Canada
8"(203mm)
8"(203mm)
Figure "A"
CAUTION: Do not open fire-door to a point where it
would be in contact with the combustible sidewall.
OPTIONAL FAN
An optional heat exchange blower is available for
this wood burning appliance. To order please see
the local dealer where you purchased your appliance.
SPRING in counter
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
OPERATION OF WOOD HEATER
Inlet Air Control Settings
Inlet Air Setting Approx. BTU Output
Closed Fully
¼ Open
¾ Open
Fully Open
Part No S19642 Rev07
9
10
(381 mm)
(1422 mm)
BACK WALL
C
F
13
11
F
11
Disposition Des Briques
Diseño de colocación de los ladrillos
ITEM NO.
PARTS LIST
NO.
DESCRIPTION
LEYENDA NO.
1 DOOR ASSEMBLY
2&3 GLASS AND GASKET
3 1/8" GLASS GASKET x 6'
4 5/8" DOOR GASKET x 6'
5
SPRING HANDLE - GOLD
5 SPRING HANDLE - NICKEL
10,467
6 AIR CONTROL SPRING HANDLE-GOLD
12,118
6 AIR CONTROL SPRING HANDLE-NICKEL
19.413
7 GLASS CLIP
26,100 8
9 HINGE PIN
10 PUSH NUT
11 FIREBRICK LT 9"x4-7/16"x1-1/4"
12 FIREBRICK LT 7-1/4"x4-7/16"x1-1/4"
13 FIREBRICK LT - ANGLED
14 FIREBRICK FOR ASH DRAWER
15 FIREBRICK LT - 4-1/2"x4-7/16"x1-1/4"
16 ASH DRAWER ASSEMBLY
MADE IN/FAB AU/HECHO EN CANADA BY CFM Corporation, 2695 Meadowvale Blrd, Mississauga, Ontario L5N 8A3 800-668-5323
1 2
5
13
11
12 12 12
12
11 11
14
11
11
15
Brick Pattern
LISTE DES PIÉCES
DESCRIPTION
PORTE MONTÉE
VITRE DE JOINT D'ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po x 6pi
JOINT DE LA PORTE 5/8po x 6pi
POIGNÉE À RESSORT - OR
POIGNÉE À RESSORT - NIKEL
POIGNÉE POUR L'ADMISSION D'AIR-OR
POIGNÉE POUR L'ADMISSION D'AIR-NIKEL
FERRURE POUR LA VITRE
SCREW VIS
GOUPILLE DE CHARNIÈRE
ÉCROU À RESSORT
BRIQUE 9"x4-7/16"x1-1/4"
BRIQUE 7-1/4"x4-7/16"x1-1/4"
BRIQUE - COUPLÉE EN ANGLE
BRIQUE POUR LE CENDRIER
BRIQUE 4-1/2"x4-7/16"x1-1/4"
L'ASSEMBLEE DE TROIR DE CENDRE
7
4
3
6
16
QTY PART NO.
LISTA DE PIEZAS
QTÉE NO.de PC
DESCRIPCIÓN
CANT. ART NO.
UNIDAD DE PUERTA 1 S31008
VIDRIO Y EMPAQUETADURA 1 S31117
EMPAQUETADURA DE 1/8" PARA EL VIDRO x 6' 1 S15001-6
EMPAQUETADURA DE 5/8" PARA LA PUERTA x 6' 1 S15011-6
1
MANGO CON RESORTE - ORO S11007
MANGO CON RESORTE - NÍQUEL 1 90000069
MANGO CON RESORTE PARA EL REGULADOR DEL AIRE-OR 1 S11008
1 90000070
MANGO CON RESORTE PARA EL REGULADOR DEL AIRE-NÍQUEL
PRESILLA PARA EL VIDRIO 6 S37034
S11086
TORNILLO 6
PASADOR DE BISAGRA 2 S11005
UNIDAD DEL DEFLECTOR 2 S11090
LADRILLO REFRACTARIO LT 9"x4-7/16"x1-1/4" 11 S16040
LADRILLO REFRACTARIO LT 7-1/4"x4-7/16"x1-1/4" 4 S16043
LADRILLO REFRACTARIO - ANGULADO 2 S16042
LADRILLO REFRACTARIO DEPÓSITO DE CENIZAS 1 S16214
LADRILLO REFRACTARIO 4-1/2"x4-7/16"x1-1/4" 1 S16048
ASAMBLEA DE CAJON DE CENIZA 1 S31297
www.cfmcorp.com
8