DutchWest CDW300007 Manual Del Usuario

This manual describes the installation and operation of the Model CDW300007 non-catalytic wood heater.
This heater meets US Environmental Protection Agency's emission limits for wood heaters. Under specific
conditions this heater has been shown to deliver heat at rates ranging from 12,000 to 55,100 BTU per hour.
Model No. CDW300007
This unit has been listed by Warnock
Hersey Limited to meet or exceed
ULC S-627-00 Canada and UL 1482 U.S.
Contact your local building inspector
prior to installation.
A permit maybe required in your area.
2ft(635mm) HIGHER THAN
NEAREST POINT OF
3FT(1M) MIN
FROM ROOF ROOF WITHIN 10ft(3M)
PENETRATION
MINIMUM OVERALL
G
HEIGHT FROM FLOOR
15FT(5M)
Unit must be placed on a noncombustible floor protection equivalent to 3/8" millboard.
Consult your local building authorities for further information.
WARNING: BEFORE REMOVING SECONDARY
AIR TUBES SUPPORT BAFFLE ASSEMBLY
BAFFLE ASSEMBLY IS VERY HEAVY
HANDLE
Twist spring handle SPRING in counter
clockwise motion while pushing on to handle;
spring handle will "thread" down to desired
location.
Desired Burn Setting
Low
Med / Low
Med / High
High
**Performance may vary depending on actual home operating conditions
MADE IN CANADA BY CFM Corporation, 410 Admiral Boulevard, Mississauga, ON L5T 2N6
NOTE: Retain this sheet for future reference
6" Flue Required
Figure A: Clearance from combustible constructions
A minimum clearance of 18" (457mm) to the chimney connector
may be required by the authority having jurisdiction.
From Heater From Chimney Connector
A Sidewall................26" (660 mm) D Sidewall.................35-1/2" (902 mm)
B Backwall...............15" (381 mm) E Backwall................18-1/2" (470 mm)
C Corner...................12" (305 mm) F Corner.....................22"
G Ceiling....................54"
BACK WALL
BACK WALL
B E
C
8"
A
D *16
**18"
C
F
8" 8"
*16"(406mm) U.S.A.
**18"(457mm) Canada
Figure "A"
CAUTION: Do not open fire-door to a point
where it would be in contact with the
combustible sidewall.
OPTIONAL FAN
An optional heat exchange blower is available
for this wood burning appliance. To order please
see the local dealer where you purchased
your appliance.
21
CAUTION: BRICK FOR ASH DRAWER
MUST BE INSTALLED BEFORE
19
OPERATION OF WOOD HEATER
20
DECORATIVE NICKEL TRIM
Be sure to remove the protective plastic
coating after installing your wood heater
Inlet Air Control Settings
Inlet Air Setting **Approx. BTU Output
Closed Fully 12,000
¼ Open 13,400
¾ Open 17,700
Fully Open 55,100
800-668-5323 www.cfmcorp.com
Part No 90000128 Rev 02
10
11
(559 mm)
(1372 mm)
F
16
18
Diseño de colocación de los ladrillos
ITEM NO.
PARTS LIST
NO.
LEYENDA NO. DESCRIPTION
1 DOOR ASSEMBLY
1 DOOR - NO GLASS
2&3 GLASS AND GASKET
1/8" GLASS GASKET
3
4 5/8" DOOR GASKET
SPRING HANDLE
5
6 AIR CONTROL SPRING HANDLE
7 GLASS CLIP
8 GLASS CLIP
9
10
HINGE PIN
11 PUSH NUT
12 NICKEL BODY TRIM
13 NICKEL ASH FENDER TRIM
14
FIREBRICK LT 7-3/4"x4-7/16"x1-1/4"
15 FIREBRICK LT 4-1/2"x4-7/16"x1-1/4"
16 FIREBRICK LT 9"x4-7/16"x1-1/4"
17 FIREBRICK LT 9"x2-1/2"x1-1/4"
FIREBRICK FOR ASH DRAWER
18
19 SECONDARY AIR TUBE
20 COTTER PIN
BAFFLE ASSEMBLY
21
5
2
1
17
16 16 16 16
16
14 14
14
16 16
16
16
14
15 16
Brick Pattern
Disposition Des Briques
LISTE DES PIÉCES
DESCRIPTION
PORTE MONTÉE
PORTE - SANS LA VITRE
VITRE DE JOINT D'ÉTANCHEITÉ
JOINT DE LA VITRE 1/8po
JOINT DE LA PORTE 5/8po
POIGNÉE À RESSORT
POIGNÉE POUR L'ADMISSION D'AIR
FERRURE POUR LA VITRE
FERRURE POUR LA VITRE
SCREW VIS
GOUPILLE DE CHARNIÈRE
ÉCROU À RESSORT
GARANTURE DU BOÎTIER EN NICKEL MOLDURA DE NÍQUEL PARA EL CUERPO DEL CALEFACTOR
GARANTURE DU GARDE FEU EN NICKEL MOLDURA DE NÍQUEL DEL PROTECTOR CONTRA LA CENTRA
BRIQUE 7-3/4pox4-7/16pox1-1/4po
BRIQUE 4-1/2pox4-7/16pox1-1/4po
BRIQUE 9pox4-7/16pox1-1/4po
BRIQUE 9pox2-1/2pox1-1/4po
BRIQUE POUR LE CENDRIER
TUBE D'AIR SECONDARE
GOUPILLE FENDUE
DÉFLECTEUR
4
3
8
9
7
12
6
13
QTY PART NO.
LISTA DE PIEZAS
QTÉE NO.de PC
CANT. ART NO.
DESCRIPCIÓN
1 90000083
UNIDAD DE PUERTA
UNIDAD DE PUERTO SIN VIDRIO 1 90000111
1 S31141
VIDRIO Y EMPAQUETADURA
4.3' S15001
EMPAQUETADURA DE 1/8" PARA EL VIDRO
EMPAQUETADURA DE 5/8" PARA LA PUERTA 5.1' S15011
1
MANGO CON RESORTE 90000069
1
MANGO CON RESORTE PARA EL REGULADOR DEL AIRE 90000070
PRESILLA PARA EL VIDRIO 1 S37026
2 S37018
PRESILLA PARA EL VIDRIO
7 S11086
TORNILLO
PASADOR DE BISAGRA 2 S11005
2 S11090
UNIDAD DEL DEFLECTOR
90000122
1
1 90000123
4 S16222
LADRILLO REFRACTARIO LT 7-3/4"x4-7/16"x1-1/4"
1 S16046
LADRILLO REFRACTARIO LT 4-1/2"x4-7/16"x1-1/4"
LADRILLO REFRACTARIO LT 9"x4-7/16"x1-1/4" 15 S16040
LADRILLO REFRACTARIO LT 9"x2-1/2"x1-1/4" 1 S16216
LADRILLO PARA DEPÓSITO DE CENIZAS 1 S16214
TUBO SECONDARIO DEL AIRE 4 S32594
S11421
ALFILER DE COTTER 4
1 S41468
ASAMBLEA DEL DEFLECTOR