Associated 6015A Manual Del Operador página 3

GROUNDING AND AC POWER CORD CONNECTION INSTRUCTIONS
19.
Charger should be grounded to reduce risk of electric shock. Charger is equipped with an electric cord having an equipment
grounding conductor and a grounding plug. The plug must be plugged into an outlet that is properly installed and grounded in
accordance with all local codes and ordinances.
- Never alter AC cord or plug provided - if it will not fit outlet, have proper outlet installed by a qualified electrician.
DANGER
Improper connection can result in a risk of an electric shock. This battery charger is for use on a nominal 120-volt circuit, and has a
grounding plug that looks like the plug illustrated in Figure (A). A
temporary adapter, which looks like the adapter illustrated in
Figures (B and C), may be used to connect this plug to a two-pole
receptacle, as shown in Figure (B), if a properly grounded outlet is
not available. The temporary adapter should be used only until a
properly grounded outlet can be installed by a qualified electrician.
- Before using an adapter as illustrated, be certain that
DANGER
center screw of outlet plate is grounded. The green-colored rigid ear or lug extending from adapter must be connected to a properly
grounded outlet - make certain it is grounded. If necessary, replace the original outlet cover plate screw with a longer screw that will
secure adapter ear or lug to outlet cover plate and make ground connection to grounded outlet.
NOTE: USE OF AN ADAPTER IS NOT ALLOWED IN CANADA. IF A GROUNDING TYPE RECEPTACLE IS NOT AVAILABLE,
DO NOT USE THIS APPLIANCE UNTIL THE PROPER OUTLET IS INSTALLED BY A QUALIFIED ELECTRICIAN.
LENGTH OF CHARGE
20.
Test the battery for state of charge. Do not charge if it is over 75% charged or the battery is determined to be defective.
a.
Set beginning amps charge rate for size of battery and state of charge per charts
b.
Charge for length of time per charge,
c.
Discontinue charge when the specific gravity of electrolyte reaches 1.260 or above. A temperature compensating hydrometer
d.
should be used for this reading. Discontinue charge if the battery begins to gas excessively or when the temperature of the
electrolyte reaches approximately 120°F. Do not overcharge batteries. Overcharging results in excessive water loss and
eventual damage to the battery.
BATTERY SIZE
Ampere Hours
Reserve Capacity
Cold Cranking Amps
STATE OF CHARGE TABLE
STATE OF CHARGE
Specific Gravity
Open Circuit Voltage 6V
Open Circuit Voltage 12V
OPERATING INSTRUCTIONS
21.
TO CHARGE BATTERIES
Make the connections to the battery per the instructions in the previous sections. Determine if the battery is 6 or 12 volts. Set
the CHARGE VOLTAGE switch to 6 VOLT for a 6 volt battery. Set the CHARGE VOLTAGE switch to 12LO for a 12 volt
battery. If a higher rate is desired, set at 12 HIGH. DO NOT charge a 6 volt battery at a setting other than 6 VOLT or charge
any battery on 12V START. (Damage may occur to the battery.) The AMMETER will show the amount of current delivered to
the battery. Length of charge should be per the above chart and instructions.
ENGINE START
Turn off all lights and accessories in the stalled vehicle. Connect the charger to battery per previous instructions. Charge the
battery on 12 HI for at least five minutes before attempting to start the vehicle. Put the switch in the START position. Start the
vehicle with the charger connected to the battery. Follow the duty cycle on the unit.
NOTE: DO NOT crank the engine more than 20 seconds in any five minute period; excessive cranking may overheat and
damage the starter. If the vehicle fails to start, while waiting for the starter to cool, allow the charger to continue to charge the
battery. Turn the switch to OFF and remove the AC power cord from the electric outlet before disconnecting the DC clamps.
BATTERY SIZE TABLE
SMALL MEDIUM LARGE
40 60
60 90
275 350
75% 50% 25%
1.225 1.185 1.140
6.2 6.05 5.95
12.4 12.1 11.9
CHARGE RATE Vs. MINUTES CHARGE
BATTERY SIZE %CHARGE
80+
100+
0-25
SMALL 25-50
400+
50-75
0-25
MEDIUM 25-50
DEAD
50-75
1.110
0-25
5.9
LARGE 25-50
11.8
50-75
3
MINUTES
15 30 45 60 75 90
40 30 25 20
40 25 20 15 10
A
M
40 20 10 10 5 5
P
45 35 30
E
R
40 30 25 20
E
30 20 15 10 10
S
55 45 40
50 40 30 25
40 25 20 15 15