Safety Warnings & Instructions; General Description; Electrical Connection - Zipper Maschinen ZI-GP1200 Manual De Instrucciones

7 SAFETY WARNINGS & INSTRUCTIONS

BEFORE START-UP, NOTE THE FOLLOWING!
Before use of the pump, please carefully read the operation instruction. Any damage due to
failure to obey by the instruction is not under the guarantee scope.


GENERAL DESCRIPTION

- Note: The pump is not suitable for use in an inflammable or explosive medium.
- Note: Dry-running of pump is prohibited.
- Note: This pump is not suitable for continuous operation (e.g. cyclic running in filter of
swimming pond or industrial equipment.)
- Risk: In accordance with product protection law we assume no responsibility for damage
due to failure to observe the stipulations herein, which is also applicable to the accessories.
- Risk: Anyone who is not familiar with operation of the pump is not allowed to operate the
pump. Children and persons below the age of 16 are not allowed to use the pump and should
be especially away from the energized pump.
- Note: This pump is suitable for conveyance of clean water. Liquid including greasy stain or
other materials would damage the pump. This pump must not be used to convey abrasive
materials, silt materials, slurry or other viscous materials. If the to-be-pumped medium
contains corrosive compositions, the corrosion resistance of the pump materials should be
considered. This pump may be used to convey daily clean water, but conveyance of
drinkable water is strictly prohibited.
- Note: This pump is protected from splash and should be fixed in a well-ventilated, dry,
damp-proof or waterproof place under ambient temperature not above 40°C. It must not
be stored or used in rain, wet room or shaft well.
 APPLICABLE SCOPE
Electrical pumps are suitable for private gardens or housework (e.g. used as fixed water-supply
unit for washing pond, washing machine, washing basin or bath shower).
- Danger: When the pump is connected with washing basin or bath shower, it is unsuitable
for conveyance of drinkable water.
- Danger: This pump is merely used in circuit provided with fault current protector (FI-switch
30mA) (VDE 0100-702 Voltage and 0100-738). When the pump is operated nearby
swimming pond, garden pond or similar places, it should be fixed at a stationary or overflow-
proof position and protected from dropping off. When anyone is in water or directly contacts
water, the pump must not be started. The installer must check the electrical connection for
being provided with earthings as per standards.


ELECTRICAL CONNECTION

Before operation, the pump must be subjected to safety inspection to ascertain whether the
pump, especially the power cable and plugs are damaged or not. Running of defective pump is
not allowed.
Earth: The connection cable of our pump is provided with two earth contacts. If the earth of the
plug-lead is selected, the socket is correspondingly earthed.
- Note: Please check whether the voltage and frequency indicated in pump nameplate are
consistent with that of the net.
- Note: In case of broken power plug the following guarantee will be invalid. It must be
replaced with genuine connection cable to the maintenance (guarantee) unit in a charging
mode. For extension of connection cable, merely the extended connection cable may be
replaced which must have an outside diameter at least equal to that of the original cable.
ZIPPER MASCHINEN GmbH
ZI-GP1200 / ZI-HWW1200N
www.Zipper-Maschinen.at
SAFETY WARNINGS & INSTRUCTIONS
9