Troubleshooting Table - Poulan Pro PP28RJ Manual De Instrucciones

TROUBLESHOOTING TABLE

WARNING:
Always stop unit and disconnect spark plug before performing all of the
recommended remedies below except remedies that require operation of the unit.
TROUBLE CAUSE
Engine will not 1. Engine flooded.
start.
2. Fuel tank empty.
3. Spark plug not firing.
4. Fuel not reaching
5. Carburetor requires
Engine will 1. Carburetor requires
not idle
properly. 2. Crankshaft seals worn.
3. Compression low.
1. Air filter dirty.
Engine will not
2. Spark plug fouled.
accelerate,
lacks power,
3. Carburetor requires
or dies under
a load.
4. Carbon build-up on
5. Compression low.
Engine
1. Fuel mixture incorrect.
smokes
excessively.
2. Air filter dirty.
3. Carburetor requires
1. Fuel mixture incorrect.
Engine runs
hot.
2. Spark plug incorrect.
3. Carburetor requires
4. Carbon build-up on
carburetor.
adjustment.
adjustment.
adjustment.
muffler outlet screen.
adjustment.
adjustment.
muffler outlet screen.
REMEDY
1. See "Starting a Flooded Engine" in
Operation Section.
2. Fill tank with correct fuel mixture.
3. Install new spark plug.
4. Check for dirty fuel filter; replace.
Check for kinked or split fuel line;
repair or replace.
5. Contact an authorized service dealer.
1. See "Carburetor Idle Speed Adjustment"
in Service and Adjustments Section.
2. Contact an authorized service dealer.
3. Contact an authorized service dealer.
1. Clean or replace air filter.
2. Clean or replace plug
and regap.
3. Contact an authorized service dealer.
4. Contact an authorized service dealer.
5. Contact an authorized service dealer.
1. Empty fuel tank and refill with
correct fuel mixture.
2. Clean or replace air filter.
3. Contact an authorized service dealer.
1. See "Fueling Engine" in Operation
section.
2. Replace with correct spark plug.
3. Contact an authorized service dealer.
4. Contact an authorized service dealer.
18