Maintenance Operation; Importante; Aivice; Analysis And Problem Solving - Skymsen EXI Manual De Instrucciones

4.6 Maintenance
4.6.1 Danger
Any maintenance with the machine in working situation is dangerous. TURN IT OFF BY PULLING
THE PLUG OFF THE SOCKET DURING MAINTENANCE.
Always unplug the machine when emergency cases arise.
4.7 Advice
Electrical or mechanical maintenance must be done by qualified personal for such operation.
Person in charge has to be sure that the machine is under TOTAL SAFETY conditions when working.
5 Analysis and Problems Solving

5.1 Problems, causes and solutions

The Juice Extractor were designed to operate with the need of minimum maintenance but the natural
wearing caused by long use of the equipment may occasionally cause some malfunctions.
If such problem occurs with your Juice Extractor
situations are listed with recommended solutions.
* Service life – 2 years for regular work shift
Problems
* *
The machine does not switch on. Lack of Electric Power.
*
Problems in the electrical circuit.
*
The crown turns but when in *
Crown groove worn out or broken.
5.2 Electrical Diagran
On/Off Switch

6. GENERAL ADVICES

- Do not wear loose fitting clothes while operating the unit. Do not use bracelets or any other piece of
jewelry. Have your hair always shortened and held up (use hair fishnets if necessary) in a way it
cannot reach any part of the machine. Roll up any loose sleeves.
- SKYMSEN is not responsible for any harm or injury caused by the negligent or inappropriate use of
this equipment by any operator. This equipment must be operated only by persons whose age equals
or exceeds 18 years old, in a safe and sound state of mind, free from the influence of any kind of drugs
and alcohol, that received proper training and instructions regarding the correct operation of this
machine, that are wearing correct and authorized safety clothes. All and any kind of modifications
carried on and applied to this machine immediately nullifies any kind of warranty and may result in
harm and injuries to the individuals operating this machine and to individuals that are located in the
machine surrounding areas while it is being operated.
- Under no circunstances place your hands in the moving parts of the machine while it is being used.
Make sure the machine has come to a complete stop before acessing the processed ingredients.
09
IMPORTANT
refer to Table 02 in which the most common
Table - 02
Causes Solutions
*
Check if plug is connected to its
*
Call technical assistance.
*
Change the crown.
Motor
Manutención
4.6
Peligros
4.6.1
Con la maquina prendida cualquier operación de manutención es peligrosa.
DESCONÉCTELA FÍSICAMENTE DE LA RED ELÉCTRICA, DURANTE
TODA LA OPERACIÓN DE MANUTENCIÓN.

IMPORTANTE

Siempre retire la enchufe del soquete en cualquier caso de emergencia.
Avisos
4.7
La manutención eléctrica o mecánica debe ser hecha por una persona
calificada para hacer el trabajo.
La persona encargada por la manutención debe certificarse que la maquina
trabaje bajo condiciones TOTALES DE SEGURIDAD.

PROBLEMAS, CAUSAS Y SOLUCIONES

5
5.1 Problemas, Causas y Soluciones
Los Exprimidores de Cítricos
mínimo de manutención. Sin embargo pueden ocurrir algunas irregularidades en su
funcionamiento, debido al desgaste natural causado por su uso.
Caso haya algún problema con su maquina, verifique la Tabla – 02 abajo,
donde están indicadas algunas soluciones recomendadas.
* La vida de servicio - 2 años para la jornada de trabajo normal
Problemas
* Máquina no prende. * Falta de Energía elétrica .
* Problema en el circuito
eléctrico interno ou externo de
la maquina
* La corona gira, pero cuando * El encaje de la corona está
entra en contacto con el desgastado o quebrado.
producto la misma para.
fueran diseñados para que se necesite un
Tabla - 02
Causas

Solucciones

* Verifique si la enchufe
está conectada al soquete y
si hay energía eléctrica en la
red eléctrica.
* Llame a la asistencia
técnica.
* Cambie la corona.
18