Preventive Maintenance - Athletic Extreme 1060T Manual De Instrucciones

PREVENTIVE MAINTENANCE

Before you use your equipment make sure it is in good condition. Check the general condition of the equipment, as
described in "Safety Information". If the equipment is not in perfect condition, contact an Authorized Technical
Assistant.
IMPORTANT: BEFORE FIRST USE, MAKE SURE THE TREADMILL IS LUBRICATED,
USAGE TIME:
- The equipment is designed for use by 1 hour continuously, after this should be turned off for at least 30 minutes for
cooling.
- Observe the time of use carefully, the equipment overheating can cause damage to the motor.
CLEANING:
- Never use abrasive or solvents for cleaning.
- Do not leave the equipment exposed to natural agents such as sunlight, rain, dew, dust, salt spray etc.
- Do not put the treadmill in dusty environments, wet, saunas or anywhere unventilated.
- Always use original spare parts. Improper maintenance can cause damage to the product and loss of warranty.
- If you prefer, this cleaning can be done by a Technical Assistant (see values).
LUBRICATION:
- Lubricate the platform every 3 months or 40h, use specific silicone for treadmills.
- If there is formation of sludge between belt and platform, call the Authorized Technical Assistant for proper
cleaning.
- Periodically check the lubrication of the belt and platform, if it´s dry do not use the treadmill, lubricate it
immediately. See below how to check lubrication:
How to check running belt for proper lubrification
- Lift one side of the running belt and feel the top surface of the running deck;
- If the surface is slick to the touch, the no further lubrification is required;
- If the surface is dry to the touch, apply propper treadmill lubricant.
How to apply lubricant
1- Lift one side of running belt;
2- Pour some lubricant under the CENTRE of the running belt on the top surface of the running deck.
3- Run on the treadmill at a 3km/h for 3 to 5 minutes to evenly distribute lubricant.
NOTE: DO NOT overly lubricate the platform. Any excess lubricant must be wiped off.
WARNING: This equipment is designed for residential use. We assume no responsibility when it is used by gyms,
clubs, clinics or condos.
IF NOT LUBRICATED, LUBRICATE BEFORE USE
16