Troubleshooting - EGO Power+ OSA1000 Manual Del Operador

TROUBLESHOOTING

CAUSE
PROBLEM
◾
◾
Olive shaker fails to
◾
start.
◾
◾
◾
Sudden stop at work
◾
◾
◾
◾
◾
Olive shaker is loud in
vibration or noise
◾
◾
The battery pack is depleted.
Battery pack breakdown
The battery pack is not properly attached to
the power head
Beyond above-mentioned reason still do
not start.
The battery pack flashes red
The battery pack flashes yellow
Olive shaker overload
Beyond above-mentioned reason still do
not start.
Piston lack of lubrication
Tine break off
Drive link is abnormal
Gear is damaged
Drive shaft spline broken
OLIVE SHAKER ATTACHMENT — OSA1000
SOLUTION
◾
Charge the battery pack with a
designated charger
◾
Replace the battery pack with a
new one
◾
Check whether the battery pack is
fully fastened
◾
Do not disassemble and inspect the
machine by yourself. Deliver it to the
designated service point for repair
◾
The electric quantity of battery pack
is too low. Please replace it with a
new battery pack or recharge and
use it again.
◾
If the battery pack is too warm,
cool it in a ventilated place for a
while and then use it again. Please
adjust the working mode to avoid
continuous high intensity use
◾
Try tapping the olive fruit with the
tip of the tine. Do not insert the tine
completely into the tree cluster.
◾
Do not disassemble and inspect the
machine by yourself. Deliver it to the
designated service point for repair
◾
Grease through the proper opening
in the lower part of the head
◾
Replace a new tine
◾
Open the upper piston guard to
check whether the drive link and
related bearing connectors are
damaged
◾
If all other parts are normal, then
only the gear is damaged. Replace
the gearbox component with a
new one
◾
Replace the tube components with
a new one.
EN
7