Transmission - Stone Mud Buggy SB1600 Manual Del Operador

Maintenance
MUD BUGGY
48

TRANSMISSION

The hydrostatic transmission is properly adjusted when no movement of the unit is visible
when controls are released.
T T T T T r r r r r ansmission R ansmission Re e e e e tur ansmission R ansmission R tur tur n t n t
ansmission R turn t tur n t n to N
The hydrostatic transmission is equipped with a self-centering device that centers the swash
plate to stop flow to the wheel motors, stopping the machine. If unit creeps one direction
when controls are released adjustment may be required. To adjust use the following proce-
dure:
1. Follow procedure in the Operation Section of this manual to Shut Off Machine.
2. Detach throttle control cables at transmission and jack front wheels off of ground.
3. Start machine. Increase engine throttle to full speed while checking for front drive
wheel rotation. If wheels rotate proceed to Step 4. If no rotation is observed shut off
machine and reattach control cables.
4. Note the directional movement of the front drive wheels. SHUT OFF MACHINE.
Loosen the lock down screw until the return arm can be rotated. If wheels were
observed moving forward—rotate return arm clockwise. If wheels were observed
moving in reverse—rotate counterclockwise. Tighten lock down screw and follow
step 3.
POTENTIAL F PO PO PO PO TENTIAL FOR SERIOUS INJUR TENTIAL F TENTIAL F TENTIAL F OR SERIOUS INJUR OR SERIOUS INJUR OR SERIOUS INJUR OR SERIOUS INJURY Y Y Y Y . CER
OPERA OPERA OPERATED WHILE RAISED OFF OF GR OPERA OPERA TED WHILE RAISED OFF OF GR TED WHILE RAISED OFF OF GR TED WHILE RAISED OFF OF GR TED WHILE RAISED OFF OF GROUND. TO PREVENT INJUR
DO NOT ATTEMPT any adjustments with the engine running. Use Extreme CAUTION while
inspecting all vehicle linkage.
o N o N eutr eutr al A al A djus djus tment tment
o N o Neutr eutral A eutr al Adjus al A djus djustment tment tment
WARNING
. CER . CER . CER . CERT T T T T AIN PR AIN PROCEDURES REQUIRE THE MA AIN PR AIN PR AIN PR OCEDURES REQUIRE THE MA OCEDURES REQUIRE THE MA OCEDURES REQUIRE THE MAC C C C C HINE T OCEDURES REQUIRE THE MA
OUND. TO PREVENT INJUR OUND. TO PREVENT INJURY Y Y Y Y , ENSURE THE MA OUND. TO PREVENT INJUR OUND. TO PREVENT INJUR
IS PR IS PR OPERL OPERL Y SECURED. Y SECURED.
IS PR IS PROPERL IS PR OPERL OPERLY SECURED. Y SECURED. Y SECURED.
Loc Loc Lock k k k k
Loc Loc
Down Down Down Down Down
Scr Scr Scre e e e e w w w w w
Scr Scr
HINE T HINE T HINE TO BE HINE T O BE O BE O BE O BE
, ENSURE THE MA , ENSURE THE MAC C C C C HINE , ENSURE THE MA , ENSURE THE MA HINE HINE HINE HINE