SPX OTC 1732 Instrucciones De Operacion Y Lista De Partes página 2

Parts List & Operating Instructions
25
24
23
22
21
19, 20
18
14, 15
Air can accumulate within a hydraulic system during shipment, or if the automatic transmission fluid (ATF) supply runs too
low. This entrapped air causes the jack to respond slowly or feel "spongy." The following procedure bleeds air from the
system.
1. Remove the jack from service, and place it on a level surface.
2. Open the release valve by turning the handle all the way counterclockwise (CCW).
3. Pump the handle six full strokes.
4. Close the release valve by turning the handle all the way clockwise (CW).
5. Pump the handle until the lift arm is fully extended.
6. Lower the lift arm by turning the handle all the way counterclockwise (CCW).
7. Test the jack for normal operation. If the lift pad doesn't rise to the correct height, repeat Steps 2–6. If this doesn't solve
the problem, call the OTC Technical Services Dept. at (800) 533-6127.
1
2
3
4
5
7, 8
9
10
11
12
13
Bleeding Air from the System
Form No. 107302, Back of Sheet 1 of 2
No. 516816 Hydraulic Assembly
Item Part
No. No. Qty.
1
513788 1
j j j j j
2 509129 1
3 512049 1
4 201433 1
j j j j j
5 221278 1
j j j j j
7 501804 1
j j j j j
8 12223 1
j j j j j
9 10268 1
10 16807 1
11 508931 1
12 512043 1
13 512044 1
j j j j j
14 513790 1
j j j j j
15 513791 1
j j j j j
18 509135 1
j j j j j
19 501236 1
j j j j j
20 221280 1
j j j j j
21 509133 1
j j j j j
22 516432 1
j j j j j
23 509130 1
j j j j j
24 14739 1
25 508822 1
Parts Included but not Shown
208676 1
512045 1
513780 1
514461 1
514462 1
Parts marked with an asterisk (
Kit No. 516817.
Description
Rod
O-ring
Reservoir Tube
Retaining Ring
Plug
Replaceable Seat
(torque to 130 in.•lbs.)
Ball
O-ring
Release Stop Screw (not shown)
Release Screw
Pump Piston
Pump Tube
(torque to 100 ft.•lbs.)
O-ring
Backup Washer
Reservoir Seal
Filter Retainer
Filter Screen
U-cup
Backup Ring
O-ring
O-ring
Gland Nut
(torque to 100 ft.•lbs.)
Retaining Ring
Spring Retainer
Compression Spring
Dust Boot
Dust Boot
j
) are included in Seal