Using The Winch - Portable Winch PCW3000-Li Instrucciones De Operación

2.4 Installing the battery.
Insert the battery (plastic part towards the compartment)
2.5 To remove the battery.
Press the battery release
button located above the
battery. This allows the battery
to easily be removed from the
device.
Open the battery's protective
cover.
Hold the handle of
PORTABLE CAPSTAN
TM
WINCH and push the battery
until you hear a "click".
Close the cover.
Hold the handle to remove the
battery.
2.6 Starting the engine.
The engine controls can be found on the engine's housing,
above the battery cavity.
Operation of the unit: Press twice to turn on and
A)
press again to turn off.
B)
Press to select the speed of the engine.
Once = 8.1 m/minute.
Twice = 9.9 m/minute.
3 times = 11.6 m/minute.
Note : A higher speed reduces the battery's operating time.
1 A
the
2.7 Capstan drum.
Your Portable Capstan Winch
diameter.
2.8 Space between drum and rope guide.
Wear on the rope guide or drum may create a gap between the
two parts that could damage the rope. Replace the rope guide
and/or drum if necessary.
3

Using the winch

3.1 Rope.
3.1.1 Type of rope.
Only use a line with low elasticity. We recommend a double braid
polyester line.
Min., max. and recommended diameters:
Min : 10 mm
▪
Max : 12-13 mm
▪
▪ Recommended : 10 mm
Contact us if you have any questions about rope types.
POLYPROPYLENE AND POLYETHYLENE LINES ARE DANGEROUS FOR
●
PULLING DUE TO THEIR ELASTICITY AND THEIR LOW MELTING POINT.
MAKE SURE THAT THE LINE IS NOT DAMAGED AND OFFERS ADEQUATE
●
RESISTANCE FOR THE LOAD TO BE PULLED.
● STRETCHING THE LINE MAY CAUSE SERIOUS INJURY. BE CAREFUL WHEN
RELEASING THE TENSION IN THE LINE.
● ALL LINES STRETCH: INCREASED LENGTH: THE MORE THE LINE IS PULLED, THE
MORE IT STRETCHES.
STRETCHING THE LINE MAY CAUSE THE LOAD TO MOVE IN AN UNEXPECTED
●
AND DANGEROUS MANNER.
STRETCHING THE LINE MAY CAUSE IT TO RELAX AND MOVE BACKWARDS
●
QUICKLY, PULLING YOUR HAND TOWARDS THE WINCH OR CAUSING
SEVERE BURNS. NEVER WIND THE LINE AROUND YOUR HAND.
1 B
THE LITHIUM-ION BATTERY IS FITTED WITH AN INTERNAL
BREAKER WHICH WILL AUTOMATICALLY STOP THE DEVICE
IN CASE OF OVERLOAD. IF THIS HAPPENS, TURN THE
DEVICE OFF BY PRESSING BUTTON "A" (SEE ILLUSTRATION).
TM
is equipped with Drum 76 mm in
MOST PULLING SITUATIONS PRESENT POTENTIAL DANGERS!
DO NOT USE A 3-STRAND YELLOW POLYPROPYLENE
LINE!
STRETCHING = DANGER!
ALWAYS WEAR GLOVES.
EN
3