Hawker ATEX WATER LESS Manual De Usuario página 3

Instructions for use Hawker
EnerSys hereby confirms that these cells (see below for description with serial number and number of the
®
EC type examination certificate, SIRA certification service, notified body number 2813) comply with the
provisions of Directive 2014/34/EU Devices and Protection Systems for Intended Use in Areas at the Risk
of Explosion. The fundamental health and safety requirements are fulfilled by compliance with the norms:
IEC 60079-0, IEC 60079-7, IEC 61241-0 and IEC 61241-1.
Signed ______________________________________________ (ATEX/IECEx authorised manager)
Serial No.: ______________________________________________________________________
Ex cell type: ____________________________________________________________________
EC type examination certificate:
IECEx Certificate of conformity:
This declaration certifies compliance with the above directives, but does not contain an assurance of
properties within the legal meaning. The safety notes of the product documentation supplied must be
observed.
Instructions for use
1. Introduction
2. Safety notes
3. Identification and area of use
4. Mounting
1. Introduction
These instructions for use contain notes for the mounting and
the safe operation of the Ex cells in vehicle batteries.
The Ex cells are components defined within the Directive
2014/34/EU (ATEX/IECEx).
For the production and use as a battery, further requirements
of the Directive must be fulfilled, which are not covered by the
component certification of the cells and are not covered by the
content of these instructions for use.
2. Safety notes
The use of various cell models inside one battery is not
permissible. This also applies for design sizes of the same
type, performance and or capacities.
The Ex cells fulfil the safety requirements in the event of
intended use.
ATEX CELLS
®
EC Declaration of Compliance
Ex cells for vehicle drive batteries
5. Commissioning
6. Operation and charging
7. Maintenance and repairs
8. Normative notes to be observed
The Special Terms and Conditions for Safe Application in
accordance with EC Type Examination Certificate Number:
SIRA 01ATEX3016U, SIRA 01ATEX3019U,
SIRA 03ATEX3087U, SIRA 03ATEX3090U
and
IECEx Certificate of Conformity Number:
IECEx
IECEx SIR07.0064U must be fulfilled.
If the cells are built together as batteries, as a minimum the
conditions set out in EN 60079-7, EN IEC60079-7 must be
observed:
•
•
•
•
•
•
•
•
•
•
•
•
3
SIRA 01 ATEX 30 ____ U
IECEx SIR 07.006 ____ U
SIR07.0061U, IECEx SIR07.0062U,
General information
Battery container
Cells
Connector
Charging of cells
Discharging of cells
Inclusion of other ignition protection types
Switching off and transport
Secondary batteries
Insulation resistance
Shock test
Ventilation
ENGLISH
IECEx SIR07.0063U,