Maintenance Instructions; Combustion In Air Adjustment - Napoleon BUILT-IN SERIE Manual Del Propietário

Maintenance Instructions

RECOMMENDATIONS
This grill should be thoroughly inspected and serviced annually by a qualified service person.
• Do not obstruct the flow of ventilation and combustion air.
• Keep the cylinder enclosure ventilation openings located on the side of the cart or enclosure and front and back of the
bottom shelf clear from debris.
WARNING! Keep the grill away from combustible materials, gasoline, and other flammable vapors and liquids.
c
omBuStion in air adjuStment
!
IMPORTANT! This must be done by a qualified gas installer.
• The air shutter is factory set and should not require adjusting under
normal conditions. Adjustments might be required under extreme field
conditions.
• The flames of the air shutter will be dark blue, tipped with light blue and
occasionally yellow when adjusted correctly.
• Too little air flow to the burner will produce soot and lazy yellow flames.
• Too much air flow to the burner will cause flames to lift erratically and
cause igniting difficulties.
Adjusting the Air Shutter
1. Remove cooking grids and sear plates. Leave lid open.
2. You may have to open the cabinet door or remove the top drawer (if
equipped) to access the air shutter screw located at the mouth of the
burner.
3. Remove the back cover to adjust rear tube burner air shutter.
4. Loosen air shutter lock
screw and open or close air
shutter as required.
5. Light the burners on high.
6. Visually inspect burner
flames.
7. Turn burners off, tighten
locking screws, and replace
removed parts when
shutters are set correctly.
8. Ensure insect screens are
installed.
Note: Infrared burners have no
air adjustment.
20
| Maintenance
(Fig. 1)
Model
Propane
BIG32RB
Natural gas
Propane
BIG38RB
Natural gas
Propane
BIG44RB
Natural gas
Propane
BI32
Natural gas
Propane
BIB10RT / BI10RT
Natural gas
Propane
BIB10IR
Natural gas
Propane
BIB12RT / BI12RT
Natural gas
Propane
BIB18RT
Natural gas
Propane
BIB18IR
Natural gas
Propane
BIB18PB
(outer ring)
Natural gas
Propane
BIB18PB
(inner ring)
Natural gas
Light Blue
Dark Blue
Burner Port
Orifice Size
Main Burner Rear Burner Main Burner
#60 1.25mm
1.45mm #50
#60 1.25mm
1.45mm #50
#60 1.25mm
1.45mm #50
#60 -
1.45mm -
#64 -
#55 -
#64 -
1.27mm -
1.2mm -
1.7mm -
1.2mm -
1.7mm -
1.15mm -
#52 -
1.75mm -
2.4mm -
1.4mm -
2.05mm -
Napoleon.com | BUILT-IN Series
!
Yellow Tip
Air Shutter
Rear Burner
1/2" Full
3/8" Full
1/2" Full
3/8" Full
1/2" Full
3/8" Full
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
- -
Fig. 1