Air Energy AE-Ti Manual De Instalación Y Operación página 43

Section 1. General Information ..................5
1.1 Introduction ......................................................... 5
1.2 Consumer Information and Safety ...................... 5
1.2.1 Spa/Hot Tub Safety Rules ............................ 5
1.2.2 Swimming Pool Energy Saving Tips ............ 6
1.3 Warranty ............................................................. 6
1.4 Codes and Standards ......................................... 6
1.5 Technical Assistance ........................................... 7
1.6 Materials Needed For Installation ....................... 7
1.6.1 Materials for All Installations ........................ 7
1.6.2 Recommended Materials for Installations .... 7
1.7 Specifications ...................................................... 7
1.7.1 General Specifications ................................. 7
1.7.2 Dimensions .................................................. 7
1.7.3 Technical Specifications ............................... 8
Section 2. Installation Instructions ...........9
2.1 General Information ............................................ 9
2.2 Location Requirements ....................................... 9
2.2.1 Introduction .................................................. 9
2.2.2 Clearances ................................................... 9
2.2.3 Equipment Pad ............................................ 9
2.2.4 Indoor Installations ....................................... 9
2.2.4.1 Condensation and Drainage .................. 9
2.2.5 Outdoor Installations .................................. 10
2.2.5.1 Lawn Sprinklers ................................... 10
2.2.5.2 Roof Run-off......................................... 10
Section 3. Water Connections .................10
3.1 Plumbing Layout .............................................. 10
3.2 Water Connections at Heat Pump .................... 11
3.3 Check Valve Installation .................................... 11
3.4 Automatic Flow Control Valve ........................... 11
3.5 Filtration System Layouts ................................. 14
3.5.1 Shared Filtration System ............................ 14
3.5.2 Independent Filtration System ................... 14
3.6 Multiple Unit Installation .................................... 14
3.6.1 Heat Pump and Heater Combination ......... 14
3.6.2 Multiple Heat Pump Connections ............... 14
Section 4. Electrical Connections ............17
4.1 General Information .......................................... 17
4.2 Main Power ....................................................... 17
4.3 Bonding (Earthing) ............................................ 17
4.4 Pump Connection (Maintain Temp Feature) ..... 17
4.5 Optional Remote Controls ................................ 22
4.5.1 Connection to a Remote Pool-Off-Spa
Selector (3-Wire Connection) ..................... 22
4.5.1.1 Install the Remote Pool-Off-Spa
Selector ................................................ 22
4.5.1.2 Configure the Control Panel ................ 22
Table of Contents
4.5.2
4.5.2.1 Configure the AquaLink RS Control
4.5.2.2
4.5.2.3
Section 5. Operation ..................................24
5.1 Initial Start-up Precautions ................................ 24
5.2 Operating the Controller ................................... 24
5.2.1
5.2.2
5.2.3
5.2.4
5.2.5
5.3 Operating Features of Units with Optional
Chiller................................................................ 25
5.3.1
5.3.2
5.3.3
5.4 User Setup Options .......................................... 26
5.4.1
5.4.2
5.4.3
5.5 Set Point Lockout .............................................. 27
5.6 Water Pressure Switch Adjustment ................... 27
Section 6. General Maintenance .............28
6.1 Water Chemistry ............................................... 28
6.2 Winterizing ........................................................ 28
6.3 Spring Start-Up ................................................. 28
6.4 Inspection and Service ..................................... 29
6.4.1
6.4.2
Section 7. Professional Maintenance
7.1 Heat Pump Design ............................................ 30
7.2 Heat Pump Components and Their
Operation .......................................................... 30
7.3 Service Setup Options ...................................... 30
7.3.1
7.3.2
7.3.3
7.3.4
7.3.5
7.3.6
7.3.7
7.3.8
7.3.9
7.3.10 Delay On Make .......................................... 32
Connection to an AquaLink RS Control
System or Remote TSTAT (2-Wire
Connection)................................................ 22
System ....................................................... 22
Install the Remote TSTAT .................... 23
Configure the Control Panel ................ 23
Off Mode .................................................... 24
Pool Mode - (Normal Heat) ........................ 24
Pool Mode - (Optional Maintain Heat) ........ 25
Spa Mode - (Normal Heat) ......................... 25
Spa Mode - (Optional Maintain Heat) ........ 25
Pool Mode - (Normal Chill) ......................... 25
Pool Mode - (Optional Maintain Chill) ........ 25
Spa Mode - (Optional Maintain Chill) ......... 26
Language Setup ......................................... 26
Temperature Scale Setup .......................... 26
Spa Timer Setup ........................................ 26
Owner Inspection ....................................... 29
Professional Inspection .............................. 29
and Service ..............................30
Maintain Temperature ................................ 30
Maintain Temperature Delay ...................... 30
Remote ...................................................... 31
Defrost Selection ........................................ 31
Test Mode .................................................. 31
Load Defaults ............................................. 31
Coil Temperature Calibration ..................... 31
Water Temperature Calibration .................. 32
Water Temperature Differential .................. 32
Page 1