Workplace Safety - Powerfix Profi 291716 Instrucciones De Servicio Y Seguridad

Please do not lower the load further than the usable length of the chain. If
14
the chain between the chain wheel and the chain pulley is pulled too taught,
this can cause damage.
Do not allow the load to come into contact with the chain hoist, otherwise
15
free rotation will be blocked, which could cause damage, knots in the chain
or barred wheels.
Regular checks and maintenance should be carried out. All damaged or faulty
16
parts must be exchanged by an expert.
The chain hoist functioning in both "with load" as well as "without load"
17
modes must be thoroughly and adequately checked.
Make sure the load weight is smaller than the stated weight of the chain hoist.
18
If in doubt, do not use the chain hoist.
19 Never overload the chain hoist.
20 Safety procedures, examinations and greasing should be carried out before
and during operation. The chain hoist should only be used if it is in proper
working order.
21 Always make sure the chain is vertical and straight, and there are no knots.
Never pull the hand chain and the load chain at an oblique angle.
22
Do not use the chain block in an explosive environment or damp rooms.
23
Examine the load chain (1), hand chain (2), fastening hook (3), load hook
24
(4), load pin (5), drive wheel (6), and latch lock (7) for defects, especially
after longer periods of standstill.
Adjust the hand chain (2) so that the point of chain reversal of the hand chain
25
(2) is at a height of between 500 and 1000 mm above the ground.
26 Pay attention to any defects which may have occurred during use. If there
are noticeable problems, immediately stop the chain block from operating.
The temperature of the surrounding atmosphere must be between -10°C and
27
+50°C in order to operate.
ADDITIONAL SAFETY INFORMATION

Workplace safety

Keep the work area orderly. Disorder in the work area can lead to accidents.
1
Provide adequate lighting at work..
2
3 Keep children and other persons away from the work area. Maintain a safe
distance from the work area.
Secure the work area by means of lockable latches, lockable main switch,
4
etc. against unauthorized access.
18 GB/IE