Maintenance & Adjustment - Troy-Bilt RZT Serie Manual Del Operador

Maintenance & Adjustments
Maintenance
WARNING! Before performing any
maintenance or repairs, disengage the PTO,
move the drive control levers fully outward in
the neutral position, engage the parking brake,
stop the engine and remove the key to prevent
unintended starting.
Engine
Refer to the Kohler Owner's Manual for all engine
maintenance intervals, procedures, specifications and
instructions.
Changing the Engine Oil
WARNING! If the engine has been recently run,
the engine, muffler and surrounding metal
surfaces will be hot and can cause burns to the
skin. Exercise caution to avoid burns.
To complete an oil change, proceed as follows:
1. Run the engine for a short time to warm the engine
oil. The oil will flow more freely and carry away more
impurities. Use care to avoid burns from hot oil.
2. Locate the oil drain hose on the left side of the engine.
Refer to Figure 6-1.
3. Route the free end of the oil drain hose toward an
appropriate oil collection container with at least a 2.5
quart capacity, to collect the used oil. Remove the oil
fill cap/dipstick from the oil fill tube.
4. While holding the free end of the oil drain hose over
the oil collection container, unscrew the square head
hose plug from the end of the hose. See Figure 6-1.
Drain the engine oil into the collection container.
Oil Fill Cap/Dipstick
Oil Fill Tube
Oil Drain Hose
Figure 6-1
5.
6.
Air Cleaner
Service the pre-cleaner and cartridge/air cleaner
element as instructed in the Kohler Owner's Manual.
Spark Plug
The spark plugs should be cleaned and the gap reset
once a season. Refer to the Kohler Owner's Manual for
correct plug type and gap specifications.
Hydrostatic Transmission
The zero turn tractor is equipped with dual integrated
hydrostatic pumps/transaxles that are sealed and are
maintenance-free. Fluid levels cannot be checked and
fluid cannot be added or changed.
General Battery Information
Oil Filter
Battery Maintenance
Square Hd.
Hose Plug
After draining the oil, wipe any residual oil from the
oil drain hose. Thread the square head plug into
the drain hose fitting and fully tighten the plug.
Replace the oil filter, and refill the engine with new
oil as instructed in the Kohler Owner's Manual.
WARNING!
• Should battery acid accidentally splatter into
the eyes or onto the skin, rinse the affected area
immediately with clean cold water. If there is
any further discomfort, seek prompt medical
attention.
• If acid spills on clothing, first dilute it with
clean water, then neutralize with a solution of
ammonia/water or baking soda/water.
• NEVER connect (or disconnect) battery charger
clips to the battery while the charger is turned
on, as it can cause sparks.
• Keep all sources of ignition (cigarettes, matches,
lighters) away from the battery. The gas
generated during charging can be combustible.
• As a further precaution, only charge the battery
in a well ventilated area.
• Always shield eyes and protect skin and clothing
when working near batteries.
• Batteries contain sulfuric acid and may emit
explosive gases. Use extreme caution when
handling batteries. Keep batteries out of the
reach of children.
6
19