Tabla de contenido
Publicidad
Preventative Maintenance • Troubleshooting • Warranty
PREVENTATIVE MAINTENANCE (cont.)
1 . Always store the transmission jack in a well protected area where it
will not be exposed to inclement weather, corrosive vapors,
abrasive dust, or any other harmful elements . The jack must be
cleaned of water, snow, sand or grit before using .
2 . Lubricate moving parts, excluding the telescopic rams, monthly with
a general purpose grease . Periodic lubrication should be subject to
a maintenance schedule based on frequency of use . A weekly
lubrication inspection is suggested . Premature wearing of
components due to lack of or inadequate lubrication is not eligible
for warranty consideration .
3 . Inspect the jack before each use . Do not use the jack if any
component is cracked, broken, bent, shows sign of damage or leaks
hydraulic fluid . Do not use the jack if it has loose or missing hardware
or components, or is modified in any way . Take corrective action
before using the jack again . Premature wearing or damage to
components caused by loose or missing hardware is not eligible for
warranty consideration .
TROUblESHOOTINg
PROblEM
1 . Unit will not lift load .
2 . Unit will not sustain load or feels "spongy" under load .
3 . Unit will not lift to full height .
4 . Unit still does not operate .
Limited Warranty...
MOUNTAIN™ bRANDED PRODUCTS ARE WARRANTED AgAINST DEFECTS IN WORkMANSHIP AND
MATERIAlS FOR A PERIOD OF ONE YEAR FROM DATE OF ORIgINAl PURCHASE.
Any Mountain™ branded product which fails to give satisfactory service due to defective workmanship or materials will be repaired or replaced at
our option during the warranty period .
Other important warranty information...
This warranty does not cover damage to equipment or tools arising from alteration, abuse, misuse, damage and does not cover any repairs or
alterations made by an unauthorized service center .
The foregoing obligation is our sole liability under this or any implied warranty and under no circumstances shall we be liable for any incidental or
consequential damages .
Note: Some states do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not
apply to you .
This warranty gives you specific legal rights and you may also have other rights which vary from state to state .
CONTACT INFORMATION:
Please contact the dealer/distributor where the item was purchased . Be certain to include with any returned products your name and address,
evidence of the purchase date, and description of the suspected defect .
MTN2156A 04/13/11
4 . It should not be necessary to refill or top off the reservoir with
hydraulic fluid unless there is an external leak . An external leak
requires immediate repair which must be performed in a dirt-free
environment by qualified hydraulic repair personnel who are
familiar with this equipment .
IMPORTANT: In order to prevent seal damage and jack failure, never
use alcohol, hydraulic brake fluid or transmission oil in the jack . Use
chevron Hydraulic Oil AW 150 32 or its equivalent Unocal Unax AW150 .
Any jack found to be defective as a result of foreign contaminants in the
hydraulic system is not eligible for warranty consideration .
5 . Every jack owner is responsible for keeping the jack labels clean and
readable . Use a mild soap solution to wash external surfaces of the
jack but not any moving hydraulic components . If product labels are
lost or not legible, contact an authorized Mountain repair center for
replacements .
6 . Do not attempt to make any hydraulic repairs unless you are a
qualified hydraulic repair person that is familiar with this
equipment . Repairs must be performed by an authorized service
center .
ACTION
Purge air from hydraulic system by following procedure under SETUP .
Purge air from hydraulic system as above .
Purge air from hydraulic system as above .
Contact a Mountain authorized hydraulic service center .
- 4 -
Publicidad
Tabla de contenido
