Additional Information - ROCK EXOTICA akimbo Manual De Instrucciones

ADDITIONAL INFORMATION

Inspect Before & After Use
-Check all parts for cracks, deformation, corrosion, wear,
sharp edges or burrs, etc.
-Verify wire gate on the SRS Chest Attachment Point is
installed.
-Verify upper cam spring is installed and provides
sufficient force against the rope to hold the Akimbo
stationary.
-Verify that the Upper and Lower Cam pivot smoothly.
-Verify that the Lower Bollard rotates smoothly.
-Verify the security of each pair of the upper and lower
friction setting pins.
-Ensure that the Upper and Lower Control Arms rotate
freely in relation to their connection to the spine.
-Ensure that the Akimbo opens and closes without
binding.
-Legibility of product markings.
Inspection During Use
Regularly inspect and monitor your system, confirming
proper connections, equipment position, fully locked
connectors, etc.
Detailed Inspection
In addition to inspection before, during and after each
use, a detailed inspection by a competent inspector must
be done at least every 12 months or more frequently
depending on amount and type of use (see following page
for inspection guidelines).
Retire from Service & Destroy if:
- Any component fails inspection
- It has been used to arrest a fall or has been significantly
loaded
- If there is any doubt about its condition.
Do not return to service until the unit in question has been
inspected and approved for use in writing by a competent
person that is authorized to do so. Contact the manufac-
turer if you have any doubts or concerns.
Environmental Factors
Moisture, ice, salt, sand, snow, chemicals and other
factors can prevent proper operation or can greatly
accelerate wear.
Compatibility
Verify compatibility with other components of your
system. Incompatible connections can cause detachment,
breakage, etc. When using multiple pieces of equipment
as a system, instructions for each piece of equipment
must be followed. Verify that each component used with
the Akimbo meets the applicable standards and or laws in
your country. EN 354:2010, EN 361:2002, EN 362:2004,
EN 365:2004, EN 565:2017, EN 566:2017, EN1891:1998,
EN12275:2013.
16
Akimbo User Instructions
Lifetime
Unlimited, but will often be much less depending on
conditions and use; it could even be a single use in some
cases.
The upper and lower cams will eventually wear down and
the Akimbo will begin to slip, even when using previously
tested settings. As the cams begin to wear, you will
need to increase the friction settings or increase the
rope diameter. Retire from service if the Akimbo fails the
function test described in this manual.
The lifespan of the Akimbo can be prolonged by avoiding
use with dirty ropes and avoiding long or fast descents.
Backup
Any time a person is suspended by a rope based system,
a secondary system should be in place in case of a
component failure. Whenever possible have a backup.
Maintenance & Storage
Clean if necessary with fresh water, then allow to dry
completely. Transport and store in a dry place away from
extremes of heat and cold and avoid chemical exposure.
Principal Material
Aluminum alloy, anodized.
Repairs or Modifications to Equipment
Are only allowed by the manufacturer or those authorized
in writing by the manufacturer.
Rock Exotica 3-year guarantee
If your Rock Exotica product has a defect due to
workmanship or materials please contact us for warranty
service. This warranty does not cover damages
caused by improper care, improper use, alterations
and modifications, accidental damage or the natural
breakdown of material over extended use and time.
If re-sold outside the original country of destination, the
re-seller must provide instructions for use, maintenance,
periodic examination and repair in the language of the
country in which this product is to be used.