Maintenance & Lubrication Charts; General - Textron Jacobsen Groom Master II 88008 Manual De Piezas Y Mantenimiento

6 MAINTENANCE & LUBRICATION CHARTS
6.1

GENERAL ________________________________________________________________

!
WARNING
Before you clean, adjust, or repair this equipment,
disengage all drives, lower implements to the ground,
engage parking brake, stop engine and remove key
from ignition switch to prevent injuries
1. Always clean the grease fitting before and after
lubricating.
2. Lubricate with grease that meets or exceeds NLGI
Air Filter (Diesel)
Air Filter (Gas)
Battery Charge
Belts
Brake
Cooling System (Diesel)
Electrical System
Engine Oil (Diesel)
Engine Oil (Gas)
Engine Oil Filter
Fuel System
Fuel Filter
Grease Fittings - All
Hydraulic Hoses and Tubes
Hydraulic Oil
Hydraulic Oil Filter
Muffler and Exhaust
Radiator Screens
Tires
A - Add or Adjust
* Indicates initial service for new machines.
** Or every two years whichever comes first.
*** Inspect visible hoses and tubes for leaks or oil marks.
**** Replace every 75 hours
- Manual grease gun with NLGI Grade 2 (Service Class
I
LB).
MAINTENANCE & LUBRICATION CHARTS
Recommended Service and Lubrication Intervals
Every Every Every
8-10 50 100
Hours Hours Hours
I AR
I C R
I
I-A* I-A
I-A*
I-C-A
I*
I R* R****
I-R* R
R* R
I
L L
I***
I-A
I R*
I
I-C/AR
I-A
C - Clean I - Inspect
Grade 2 LB specifications. Apply grease with a
manual grease gun and fill slowly until grease begins
to seep out. Do not use compressed air guns.
3. Periodically apply a small amount of lithium based
grease to the seat runners.
4. For smooth operation of all levers, pivot points and
other friction points that are not shown on the
lubrication chart apply several drops of SAE 30 oil
every 40 hours or as required.
5. Grease fittings every 50 hours.
Every Every Every
250 400 500
Hours Hours Hours
R
A
I
R
L
I
R**
R
I
L- Lubricate R - Replace
II - Engine Oil - See Section 4.3
III - Use Jacobsen hydraulic fluid: Capacity: 5 gallons
(19 Liters). Order Part No. 5003103 for 5 gal. (19 liter),
pail. Order Part No. 5003102 for 55 gal. (208 liter) drum
IV - Capacity: 3qt. (2.8 l) 50/50 water ethylene glycol mix
Every Yearly See
1000 Section
Hours
R 4.4
R 4.5
4.8
4., 3.2
R 4.19
4.14
4.3
4.3
4.7
4.7
4.11
4.12
4.13
4.15
4.19
4.16
AR - As Required
6
Lubricant
Type
IV
II
II
I
III
GB-21