Ego Power+ PTX5100 Manual Del Operador página 10

LUBRICATING THE BLADE (Fig. N)
EN
For best operation and longer blade life, lubricate the hedge
trimmer blade with anti-rusting oil after each use. DO NOT
FULLY FILL OIL HOLE WITH THE OIL.
1. Remove the oiling hole screw on the gear case by a
hex wrench (not included).
N-1 Oiling Hole Screw
2. Inject 5g grease through the greasing hole to the
gearcase.
3. Tighten the screw once finished.
LUBRICATING THE DRIVE GEAR
For best operation and longer lifetime, lubricate the hedge
trimmer attachment drive gear with a special grease every
100 hours operation.
The grease should meet the following requirements:
◾
NLGI Grade Penetration: NLGI-2;
◾
Thickener Type: Polyurea;
◾
Recommended Operating Temperature Range: -40°C
to 180°C;
◾
Other than above, the grease should also be shear
stable with exceptional pressure characteristics and
excellent anti-wear property, and perfect oxidation
stability.
Follow the steps below to fill with the grease:
1. Switch off the tool and remove the battery pack.
2. Use a hex wrench (not included) to loosen and
remove 3 short screws (O-1) on the motor cover
(O-2) and then detach the motor cover (Fig. O).
O-1 Short Screw
O-2 Motor Cover
O-3 Short Screw
O-4 Motor
3. Loosen the 3 short screws (O-3) on the motor and
then detach the motor and the washer.
4. Use a grease gun (not included) to inject 5g grease at
the center of the 3 upper planet gears (O-7) into the
gear case.
NOTE:
Ensure the position of other parts near the gear
case remains unchanged during injection.
5. Reassemble the washer and the motor by tightening
the 3 short screws (O-3).
6. Reassemble the motor cover by tightening the 3
short screws (O-1).
10
56-VOLT LITHIUM-ION HEDGE TRIMMER ATTACHMENT — PTX5100
O-5 Washer
O-6 Gear Case
O-7 Planet Gears
7. Start the tool to check whether it can work normally.
If it does not, reassemble by following above steps.
NOTE:
After removing the motor cover, clean up the
sawdust around the motor.
Protecting the environment
Do not dispose of electrical equipment,
battery charger and batteries/
rechargeable batteries into household
waste!