Maintenance And Inspection - Metabo HPT SV 1813DA Manual De Instrucciones

MAINTENANCE AND INSPECTION

WARNING
● Be sure to turn off the switch and pull out the battery before doing any inspection or maintenance.
1. Emptying and cleaning the dust bag (Fig. 16)
If the dust bag contains too much dust, dust collection
will be aff ected. Empty the dust bag when it gets full.
Remove the dust bag, detach the closure band and
dispose of the contents.
Dust bag
2. Inspecting the sanding paper
Since use of worn-out sanding paper will degrade
effi ciency and cause possible damage to the pad,
replace the sanding paper as soon as excessive
abrasion is noted.
3. Inspecting the screws
Regularly inspect all screws and ensure that they
are fully tightened. Should any of the screws be
loosened, retighten them immediately.
CAUTION
Using this power tool with loosened screws is
extremely dangerous.
4. Maintenance of the motor
The motor unit winding is the very "heart" of the
power tool. Exercise due care to ensure the winding
does not become damaged and/or wet with oil or
water.
Duct
Closure band
Fig. 16
5. Inspection of terminals (tool and battery)
Check to make sure that swarf and dust have not
collected on the terminals.
On occasion check prior, during and after operation.
CAUTION
Remove any swarf or dust which may have collected
on the terminals.
Failure to do so may result in malfunction.
6. Check for Dust
WARNING
Wear protective glasses and a dust mask when
cleaning the fi lter with an air gun.
Failure to do so may result in inhalation or
exposure of the eyes to debris or dust.
Use an air gun or other similar tool to remove
materials, chips, etc. which have adhered to the
body, and wipe with a soft dry cloth or a cloth
moistened with soapy water. Do not use chloric
solvents, gasoline or paint thinner, for they melt
plastics.
7. Disposal of the exhausted battery
WARNING
Do not dispose of the exhausted battery. The
battery must explode if it is incinerated. The
battery is recyclable. At the end of it's useful
life, under various state and local laws, it may
be illegal to dispose of this battery into the
municipal waste stream. Check with your local
solid waste offi cials for details in your area for
recycling options or proper disposal.
8. Storage
Storing in a place below 104°F (40°C) and out of the
reach of children.
English
17