Publicidad
IO-Link Data Dictionary
10.03.01.00648
IO-Link Implementation
Vendor ID
Device ID
SIO-Mode
IO-Link Revision
IO-Link Bitrate
Minimum Cycle Time
Process Data Input
Process Data Output
Process Data
Process data In
Signal SP2
Signal SP1
Signal SP3
CM-Autoset acknowledged
Signal SP2 X11
PD in byte 0
Signal SP2 X12
Device status
PD in byte 1
Profile select acknowledge
PD in byte 2
Errors, High-Byte
PD in byte 3
Errors, Low-Byte
PD in byte 4
Warnings, High-Byte
PD in byte 5
Warnings, Low-Byte
Bits
Access
0
ro
1
ro
2
ro
3
ro
4
ro
5
ro
6...7
ro
0...7
ro
0...7
ro
0...7
ro
0...7
ro
0...7
ro
J. Schmalz GmbH
Johannes-Schmalz-Str. 1, D 72293 Glatten
Tel.: +49(0)7443/2403-0
www.schmalz.com
info@schmalz.de
234 (0xEA)
100336 (0x187F0)
yes
1.1
38.4 kBit/sec (COM2)
6 ms
12 bytes
2 bytes
Remark
Vacuum is over SP2 and not yet under rP2
Vacuum value within setpoint area
The part has been detached after a suction cycle
Acknowledge that the autoset function has been completed
Vacuum is over SP2 and not yet under rP2 for X11
Vacuum is over SP2 and not yet under rP2 for X12
00 - [green] Device is working optimally
01 - [yellow] Device is working but there are warnings
10 - [orange] Device is working but there are severe warnings
11 - [red] Device is not working properly
Active Profile
Bit 0 = Internal error: data corruption
Bit 1 = Temperature overrun
Bit 2 = Primary voltage too low
Bit 3 = Primary voltage too high
Bit 4 = Auxiliary voltage too low
Bit 5 = Auxiliary voltage too high
Bit 6 = Short circuit at OUT2
Bit 7 = Short circuit at OUT3
Bit 8...9 = reserved
Bit 10 = Sensor calibration failed
Bit 11 = Pump not working properly
Bit 12...14= reserved
Bit 15 = IO-Link communication interruption
Bit 0 = reserved
Bit 1 = Evacuation time above limit
Bit 2 = Leakage rate above limit
Bit 3 = SP1 not reached in suction cycle
Bit 4 = Free Flow Vacuum over SP2
Bit 5 = Primary Voltage US out of operating range
Bit 6 = Auxiliary voltage UA out of operating range
Bit 7 =Temperature out of operating range
Bit 8 = Vacuum sank under rP2 during suction
Bit 9...15 = reserved
GCP
09.12.2022
Publicidad
