Carbest LiFePO4 Li100 Manual Del Usuario página 17

8. TROUBLESHOOTING
DE
No. Symptom Possible Causes
EN
Battery being protected
IT
1 No DC output
by BMS
ES
The charging voltage is
too low and the battery
FR
cannot be fully charged
The load voltage
is too high and the
NL
Battery working
battery cannot be fully
2 time is too
discharged
short
FI
Over temperature
DK
Battery capacity
becomes lower
SE
Over current
3 Battery heat up
Over temperature
Initial connect to
capacitive load or
Spark occurs
inductive load
4 on cable
terminals
Power supply short
circuit
9. MAINTENANCE AND STORAGE
• The CARBEST LiFePO4 batteries are basically absolutely maintenance-free.
• Keep the battery clean and use a moistened cloth for cleaning.
• Do not expose the product to solvents or other aggressive liquids.
• Please ensure the battery terminals and screw holes are clean and securely connected.
• If the battery is not used for a longer period of time, it should first be fully charged. Check the
state of charge regularly and recharge the battery if necessary. We recommend recharging the
battery with a suitable charger after each use or at least every 3-6 months. Do not use a trickle
charger.
• If the battery is not used for a longer period of time (several months), disconnect the battery
from the load to avoid unnoticed discharge.
• Always store the product in a dry, clean and frost-free place.
CARBEST | LiFePO4 Battery | 81451 / 81452 / 81453
Corrective Actions
Check the circuits/working environment and
confirm the load power, to ensure the battery
is being charged/discharged within the max.
charging/discharging current stated in the
specifications
Adjust the charging voltage according to the
specifications.
Reduce the load voltage or replace the
battery with a larger capacity one
Lower down ambient temperature
Replace the battery
Reduce load power
Working within the operating temperature
No action required
Check the cause of the short circuit and
disconnect it
32
CARBEST | LiFePO4 Battery | 81451 / 81452 / 81453
Item
Less than 1 month
Storage
Less than 3 months
Temperature
More than 3 months
Relative Humidity
SOC (States of Charge)
• Never open the battery casing. This does not contain any parts that require care or maintenance.
10. TRANSPORT INSTRUCTIONS
• If you wish to return your battery, always use the original packaging.
• The batteries may only be transported or shipped in the original packaging. If alternative packag-
ing is used, the corresponding regulations must be observed.
• The batteries must be transported in accordance with the UN Manual of Tests and Criteria, Part
III, subsection 38.3.
• With regard to transport, the batteries belong to category UN3480, Class 9A.
• The original packaging complies with these requirements.
11. WARRANTY
The warranty period is 5 years. Reimo reserves the right to rectify eventual defaults.
The guarantee is excluded for all damages caused by faulty use or improper handling.
Liability limitations: In no case Reimo will be reliable for collateral-, secondary- or indirect
damages, costs, expenditure, missed benefits or missed earnings. The indicated sales price of the
product is representing the equivalent value of Reimo's liability limitations.
12. DISPOSAL
Please dispose of all packaging material properly or recycle it. You are legally obligated to return
used batteries. Never dispose of LiFePO4 batteries in household or commercial waste!
Instead, you must take the batteries to collection points for professional recycling. Alternatively,
you can contact your dealer, repair store or the manufacturer for return.
When disposing of the battery, make sure that it is completely discharged and insulate the battery
terminals to prevent short circuits.
Criteria
-10°C ~ +45°C
-10°C ~ + 35°C
0°C ~ +30°C
≤75% RH
40% ~ 60%
33
DE
EN
IT
ES
FR
NL
FI
DK
SE