Maintenance Schedule & Daily Check List - Joerns Oxford Calibre Manual De Instrucciones

Oxford
®
Calibre
9. Maintenance Schedule & Daily Check List
All Oxford products are designed for minimum maintenance, however some safety checks and
procedures are required. A schedule of DAILY tasks are detailed below. Daily checks and a six
monthly service, inspection and test will ensure a lift is kept in optimum safe working condition. A
list of spare parts is available upon request.
The LOAD TEST and certification should only be carried out by qualified personnel or an authorised
service agent / dealer.
DAILY CHECK LIST: Joerns Healthcare strongly recommends the following checks be carried out
on a daily basis and before using lift.
• MAKE SURE the lift moves freely on its castors.
• MAKE SURE the 6-point cradle is free to rotate and swing
• EXAMINE & CHECK that the 6-point cradle is firmly attached to the boom.
• EXAMINE the sling hooks/clips on the 6-point cradle for excessive wear.
• MAKE SURE the legs open and close correctly.
• OPERATE the hand control to confirm the boom raises and lowers satisfactorily.
• CHECK the operation of the emergency stop button.
• EXAMINE slings for fraying or other damage. DO NOT use any sling if damaged or if the
sling shows signs of wear.
• CONFIRM the lift is not giving a low battery alarm when the hand control is operated. If the
alarm sounds, DO NOT use, and place on charge immediately.
• MAKE SURE the actuator connection points are secure.
Maintenance, Inspection and Test
Joerns Healthcare recommend a thorough inspection and test of the Oxford Calibre lift and lifting
accessories, slings, scales etc is carried out on a regular basis. Inspection frequency varies
depending on locality, so you must check with your dealer or local government agency as
appropriate regarding how often an inspection is required. The examination and test should be
conducted according to the recommendations and procedures provided in this manual. Joerns
Healthcare recommends maintenance, inspection and certified testing is carried out by authorised
service agent / dealers only.
NOTE: These recommendations are in compliance with the requirements of 1998 No2307 Health
and Safety: The Lifting Operations and Lifting Equipment Regulations 1998. This is a UK
regulation. Outside the UK please check your local country requirement
22
English