Ingersoll Rand 650554 Guia De Inicio Rapido

OPERATOR'S MANUAL
INCLUDING: OPERATION, INSTALLATION & MAINTENANCE
INCLUDE MANUALS: 66302 X LOWER PUMP END (PN 97999 648), 650485 X PUMP (97999 654), 65142X X
FILTER (97999 6), R272X1 XXX REGULATOR (PN 100400 6) & GENERAL INFORMATION S 636 (97999 636)
AIRLESS SPRAY PUMP SYSTEM - CART MOUNTED
SISTEMA DE BOMBA PULVERIZADORA SIN AIRE - MONTADO EN CARRETILLA
SYSTÈME DE POMPE DE PULVÉRISATION SANS AIR - MONTÉ SUR CHARIOT
4-1/4" STAINLESS STEEL, TWO BALL PUMP, 30:1 RATIO
SERVICE KITS
• Use only genuine ARO
replacement parts to assure compatible
R
pressure rating and longest service life.
• 61268 for repair of Air Motor section.
Service Note: The Air Motor Service / Parts Manual is not shipped
with the pump but it is included with each Service Kit. If this Service
/ Parts Information is needed, request the Air Motor Operator's
Manual from ARO. (Manual 6544X X, PN 97999 64).
• 637307 P43 for repair of Lower Pump section.
PUMP SYSTEM DATA
Model . . . . . . . . . . . . . . . . . . .
Pump System Type . . . . . . . . .
Pump Model . . . . . . . . . . . . . .
Ratio . . . . . . . . . . . . . . . . . . . .
Air Inlet . . . . . . . . . . . . . . . .
Air Exhaust . . . . . . . . . . . . .
Material Inlet . . . . . . . . . . . . .
Dimensional Data . . . . . . . . .
Air Motor . . . . . . . . . . . . . . . . .
Motor Repair Kit . . . . . . . . . .
Lower Pump End . . . . . . . . . . .
Lower Pump Repair Kit . . . .
Weight (less carton) . . . . . . .
PERFORMANCE
Air Inlet Pressure Range . . . . .
Fluid Pressure Range . . . . . . .
Max. Rec'd Cycles / Minute . . .
3
Displacement In Per Cycle . . .
Volume / Cycle . . . . . . . . . . . .
Cycles Per Gallon . . . . . . . . . .
Flow @ 60 Cycles / Minute . . .
Noise Level @ 60 Psi 40 Cpm 81.8 db(A)
* The pump sound pressure level has been updated to an Equivalent Continuous Sound Level
(L ) to meet the intent of ANSI S1. 13 1971, CAGI PNEUROP S5.1 using four microphone
Aeq
locations.
OPERATING INSTRUCTIONS
DO NOT EXCEED MAXIMUM OPERATING PRESSURE
WARNING
OF 4500 P.S.I.(310BAR)AT 150 P.S.I.(10.3BAR)AIRINLETPRESSURE.
REFER TO THE PUMP MANUAL FOR ADDITIONAL OP
WARNING
ERATING AND SAFETY PRECAUTIONS AND OTHER IMPORTANT IN
FORMATION.
INGERSOLL-RAND COMPANY
P.O. BOX 151 ONE ARO CENTER
D
&
D
(419) 636-4242 FAX (419) 633-1674
READ THIS MANUAL CAREFULLY BEFORE INSTALLING,
OPERATING OR SERVICING THIS EQUIPMENT.
650554
Cart Mounted Portable,
Air Operated, Two Ball S'Steel
650485 P43
30:1
1/2" 14 N.P.T.F. 1 (female)
Muffler included
Suction Tube
See page 3
65465 B
61268
66302 P43
637307 P43
108 Lbs (49 Kgs)
30 150 p.s.i. (2 10.3 bar)
900 4500 p.s.i. (62 310 bar)
60
5.5
3 oz. (90.3 ml)
41.9
1.3 g.p.m. (4.9 lpm)
BRYAN, OHIO 43506 0151
D
E
2000 D PRINTED IN U.S.A.
RELEASED / LIBERADO / DECHARGE: 2-10-96
REVISED / REVISADO / REVISE:
650554
Inlet Air Regulator and Material Outlet ManIfold are not shown, see Fig. 2
El regulador de entrada de aire y el distribuidor de salida de materiales no se muestran, ver la figura 2.
Régulateur d'entrée d'air et tubulure de sortie de matériel non montrés, voir Fig. 2
IMPORTANT This is one of the six documents which support
the system. Replacement copies of these forms are available
upon request.
- 66302 X LOWER PUMP END OPERATOR'S MANUAL
(97999 648)
= 650554 PUMP SYSTEM MANUAL (97999 671)
- 650485 X PUMP MODEL OPERATOR'S MANUAL (97999 654)
- 65142X X MATERIAL FILTER (97999 6)
- R272X1 XXX REGULATOR OPERATOR'S MANUAL (100400 6)
- GENERAL INFORMATION MANUAL S 636 (97999 636)
650554
11-15-00
(REV. C)
FIGURE 1