Página 1 4241724-ES-Rev A By Jacobsen Parts & Maintenance Manual Manual de piezas y mantenimiento Cushman Turf Truckster ® ® With Four Post ROPS Con sistema de protección antivuelco de cuatro puntos ® 84063 – Kubota D1105-E3B Diesel Engine, MT ® 84064 – Kubota D1105-E3B Diesel Engine, MT, EC ®...
Página 2: Service Parts
FOREWORD This manual contains adjustment, maintenance, The serial plate is located on the frame rail under the troubleshooting instructions and parts list for your new steering wheel. Jacobsen recommends you record these ® numbers below for easy reference. Jacobsen machine. This manual should be stored with the equipment for reference during operation.
Página 3: Tabla De Contenido
Table of Contents Safety 5.11 Charging Battery ........22 Operating Safety ........4 5.12 Hydraulic Hoses ........23 Important Safety Notes ......5 5.13 Hydraulic Reservoir and Filter ....23 Vehicle Identification Numbers 5.14 Fuel ............24 Vehicle Identification Number ....6 5.15 Fuel System ..........24 Engine Identification Numbers ....
Página 4: Safety
SAFETY SAFETY OPERATING SAFETY ______________________________________________________ WARNING EQUIPMENT OPERATED IMPROPERLY OR BY UNTRAINED PERSONNEL CAN BE DANGEROUS. Familiarize yourself with the location and proper use of all controls. Inexperienced operators should receive instruction from someone familiar with the equipment before being allowed to operate the machine. 1.
Página 5: Important Safety Notes
SAFETY IMPORTANT SAFETY NOTES ________________________________________________ This safety alert symbol is used to alert you to potential hazards. DANGER - Indicates an imminently hazardous situation which, if not avoided, WILL result in death or serious injury. WARNING - Indicates a potentially hazardous situation which, if not avoided, COULD result in death or serious injury.
Página 6: Vehicle Identification Numbers
VEHICLE IDENTIFICATION NUMBERS VEHICLE IDENTIFICATION NUMBERS VEHICLE IDENTIFICATION NUMBER _________________________________________ The Vehicle Identification Number (VIN), consisting of the model number, date code, and serial number, is printed on the Nameplate/Identification Decal attached to the CHARLOTTE, NC, USA cross member under the dash. 1 800 848 1636 Jacobsen.com The serial number is also stamped on the cross member.
Página 7: Specifications
SPECIFICATIONS SPECIFICATIONS PRODUCT IDENTIFICATION _________________________________________________ 84063 ......Turf Truckster, liquid cooled differential, and four post ROPS. diesel engine, 4 speed manual 84068 ......Turf Truckster liquid cooled gas transmission, 11.16:1 2 speed engine, 3 speed automatic differential, mechanical PTO, transmission, 14.21:1 2 speed and four post ROPS.
Página 8: Vehicle
SPECIFICATIONS VEHICLE_________________________________________________________________ ires: actuated Front ....... 20 x 10 - 10 Multi Rib Steering ......Front wheel power steering Rear ......24 x 13 -12 Titan Ultra Trac Hitch Capacity: Tire Pressure: Max. trailer GVWR..1500 lb. (680 kg) Tounge Weight..200 lb. (90.7 kg) Front .......
Página 9: Accessories & Support Literature
SPECIFICATIONS ACCESSORIES & SUPPORT LITERATURE _____________________________________ Contact your area Jacobsen Dealer for a complete listing of accessories and attachments. CAUTION Use of other than Jacobsen authorized parts, excluding emission related components defined in the Emission Warranty, and accessories may cause personal injury or damage to the equipment. Flatbeds and Boxes Hydraulic Attachments 47 in.
Página 10: Declaration Of Conformity
SPECIFICATIONS DECLARATION OF CONFORMITY ____________________________________________ DECLARATION OF CONFORMITY PROHLÁŠENÍ O SHOD OVERENSSTEMMELSESERKLÆRING CONFORMITEITSVERKLARING VASTAVUSDEKLARATSIOON VAATIMUSTENMUKAISUUSVAKUUTUS DECLARATION DE CONFORMITE KONFORMITÄTSERKLÄRUNG MEGFELEL SÉGI NYILATKOZAT DICHIARAZIONE DI CONFORMITÀ ATBILST BAS DEKLAR CIJA ATITIKTIES DEKLARACIJA DIKJARAZZJONI TAL-KONFORMITÀ DEKLARACJA ZGODNO CI DECLARAÇÃO DE CONFORMIDADE DECLARA IE DE CONFORMITATE VYHLÁSENIE O ZHODE IZJAVA O SKLADNOSTI DECLARACIÓN DE CONFORMIDAD DEKLARATION OM ÖVERENSSTÄMMELSE Business name and full address of the manufacturer Obchodní...
Página 11 SPECIFICATIONS Harmonised standards used Použité harmonizované normy Brugte harmoniserede standarder Gebruikte geharmoniseerde standaards Kasutatud ühtlustatud standardid Käytetyt yhdenmukaistetut standardit Normes harmonisées utilisées BS EN ISO 20643 Angewandte harmonisierte Normen Harmonizált szabványok Standard armonizzati applicati BS EN ISO 5349-1 Izmantotie saska otie standarti Panaudoti suderinti standartai Standards armonizzati u ati Normy spójne powi zane Normas harmonizadas usadas BS EN ISO 5349-2 Standardele armonizate utilizate Použité...
Página 12: Adjustments
If proper running. adjustment cannot be made, contact an authorized Cushman Dealer. ENGINE ACCESS__________________________________________________________ Never remove or install the engine cover while the engine is running. The engine cover is a machinery guard and its removal exposes you to moving parts.
Página 13: Front Cowl Access
ADJUSTMENTS FRONT COWL ACCESS_____________________________________________________ The front cowl opens to gain access to two access panels, fuse panel, horn, and master cylinder reservoir. Pull Lever To open the front cowl locate the release lever at the To Release Cowl Latc h upper left corner of front clip near the left side headlight.
Página 14: Diesel Alternator Belt
ADJUSTMENTS DIESEL ALTERNATOR BELT ________________________________________________ Inspect and adjust new belt after first 24-48 hours of operation. Adjust every 200 hours thereafter. Adjust alternator pulley so belt deflects 1/4 to 1/2 in. (6 to 12 mm) with a 20 lb. push at midpoint between water pump and alternator pulleys.
Página 15: Gas Hydraulic Pump Belt
ADJUSTMENTS GAS HYDRAULIC PUMP BELT _______________________________________________ Inspect new belt after first 24-48 hours of operation. Belt is dynamically adjusted with a spring loaded tensioner to 12 ft-lbs. No adjustment is required. To remove belt rotate tensioner towards radiator to release tension and remove belt from pulleys. Figure 4I PARKING BRAKE CABLE ___________________________________________________ 1.
Página 16: Torque Specification
All torque values included in these charts are approximate and are for reference only. Use of these torque values is at your sole risk. Cushman is not responsible for any loss, claim, or damage arising from the use of these charts.
Página 17: Maintenance
Authorized Recycle or dispose of all hazardous materials Cushman Dealer. (batteries, fuel, lubricants, anti-freeze, etc.) according to federal, state, and local regulations. Inspect the equipment on a regular basis, establish a maintenance schedule, and keep detailed records.
Página 18: Engine
MAINTENANCE ENGINE OIL ______________________________________________________________ Check the engine oil at the start of each day before starting the engine. To check the engine oil remove the dipstick and wipe it Oil Level Must with a clean rag. Reinsert the dipstick until it contacts the Be Between Marks Engine Dipstick oil tube.
Página 19: Power Steering Reservoir
MAINTENANCE POWER STEERING RESERVOIR _____________________________________________ When checking the fluid level before the engine has been warmed up the level should be at the COLD mark on the WARNING dipstick. After the engine has been warmed up and the fluid is warm the level should be between the COLD and Before servicing or doing any maintenance work ®...
Página 20: Cooling System
6. If you have to add coolant more than once a month, negative battery cable or removing the fan fuse. or add more than one quart at a time, have a authorized Cushman Dealer check the cooling NEVER add straight antifreeze to the radiator. Mix equal system.
Página 21: Air Filter
MAINTENANCE AIR FILTER _______________________________________________________________ Do not remove the element for inspection or cleaning. 5. Unsnap retaining clamps and remove the old Unnecessary removal of the filter increases the risk of element as gently as possible and discard. injecting dust and other impurities into the engine. 6.
Página 22: Battery
MAINTENANCE 5.10 BATTERY ________________________________________________________________ Make absolutely certain the ignition switch is OFF and 1. When installing the battery, always assemble the Positive (RED) (+) battery cable first and the the key has been removed before servicing the battery. Negative (BLACK) (-) battery cable last. CAUTION 2.
Página 23: Hydraulic Hoses
MAINTENANCE 5.12 HYDRAULIC HOSES _______________________________________________________ IMPORTANT: The hydraulic system can be permanently damaged becomes WARNING contaminated. Before disconnecting any hydraulic component clean the area around the fittings and the To prevent serious injury from hot, high pressure oil hose ends to keep impurities out of the system. never use your hands to check for oil leaks;...
Página 24: Fuel
MAINTENANCE 5.14 FUEL ____________________________________________________________________ Handle fuel with care - it is highly flammable. Use an 4. Check fuel lines and clamps every 50 hours. approved container. The spout must fit inside the fuel Replace fuel lines and clamps at the first sign of filler neck.
Página 25: Tire Pressure
MAINTENANCE 5.16 TIRE PRESSURE __________________________________________________________ Keep tires properly inflated to prolong tire life. Check Rear - Varies, determined by load. (See Chart) inflation pressure while the tires are cool. Inspect tread 28 (1.93) wear. 23 (1.59) Lower pressure will help avoid leaving tire marks in soft turf.
Página 26: Raising The Vehicle
MAINTENANCE 5.18 RAISING THE VEHICLE_____________________________________________________ Block Tire Here WARNING Make sure the vehicle is parked on a solid and level surface. Never work on a vehicle that is supported only by a jack. Always use jack stands. Whenever possible empty the truck bed before raising the vehicle.
Página 27: Towing The Vehicle
MAINTENANCE 5.19 TOWING THE VEHICLE _____________________________________________________ 4. Slowly drive towing vehicle forward until tow-line is pulled tight. WARNING 5. While towing, try to keep the tow-line taught at all To prevent injury or vehicle damage the following times. Be careful going down inclines and turning guidelines should always be followed.
Página 28: Hydraulic Brakes
MAINTENANCE 5.21 HYDRAULIC BRAKES ______________________________________________________ 4. Repeat Step 3 for each brake. WARNING 5. Most communities have a disposal system for DOT 3 brake fluid. Please dispose of fluids properly. Improper maintenance of the brake system may result in loss of vehicle control by the operator. Losing control of the vehicle due to brake loss may cause injury to the operator or bystanders and vehicle Brake Fluid...
Página 29: Differential Fluid
MAINTENANCE 5.22 DIFFERENTIAL FLUID ______________________________________________________ The differential fluid should be checked every 100 hours or 3 months. Fluid should be changed after the first 100 hours and every 600 hours (or yearly) thereafter. Differential Fluid Capacity ..3 qts (2.84 l) Level Check And Fluid Type ......
Página 30: Gas Engine Manual Transmission
MAINTENANCE 5.24 GAS ENGINE MANUAL TRANSMISSION_______________________________________ The transmission fluid should be checked every 100 hours or 3 months. Fluid should be changed every 600 Fill transmission with gear lube until fluid begins to leak hours (or yearly). from hole. Apply pipe thread sealant and install filler plug. Transmission Fluid Capacity ..
Página 31: Electrical System
MAINTENANCE 5.26 ELECTRICAL SYSTEM _____________________________________________________ Diesel Engine CAUTION 20 A Dash Panel, Power Port 15 A Fuel Pump Always turn the ignition switch to the OFF position and & Ignition Brake Light, remove the Negative (BLACK) battery cable before 5th Wheel Brake 10 A 10 A Accessary...
Página 32: Headlight Replacement
MAINTENANCE Tachometer DIP Switch Setting: Using a small blade screwdriver or similar tool push the switch levers either up or down to match the sequence The dash panel uses a DIP Switch sequence code to code for this unit. identify the number of input pulses per engine revolution and engine type to correctly display the engine RPM on Diesel Engine Setting Gas Engine Setting...
Página 33: Efi Diagnostic Check
1. Use compressed air to clean engine and radiator fins. A special blow gun is available through Cushman Dealer. 2. Use only fresh water for cleaning your equipment. Note: Use of salt water or affluent water has been known to encourage rust and corrosion of metal parts resulting in premature deterioration or failure.
Página 34: Storage
MAINTENANCE 5.32 STORAGE________________________________________________________________ General Engine (General) 1. Wash the vehicle thoroughly and lubricate as 1. While the engine is warm remove the drain plug, necessary. Repair and paint damaged or exposed drain the oil from the crankcase, and change oil filter. metal.
Página 35: Troubleshooting
TROUBLESHOOTING TROUBLESHOOTING GENERAL ________________________________________________________________ The troubleshooting chart below lists basic problems that detailed information regarding the electrical system may occur during start up and operation. For more contact your area Jacobson Dealer. Symptoms Possible Causes Action Engine will not start. 1.
Página 36: Maintenance & Lubrication Charts
MAINTENANCE & LUBRICATION CHARTS MAINTENANCE & LUBRICATION CHARTS GENERAL________________________________________________________________ 2. Lubricate with grease that meets or exceeds NLGI Grade 2 LB specifications. Apply grease with a WARNING manual grease gun and fill slowly until grease begins to seep out. Do not use compressed air guns. Before you clean, adjust, or repair this equipment, disengage all drives, lower implements to the ground, 3.
Página 37: Maintenance Charts
MAINTENANCE & LUBRICATION CHARTS MAINTENANCE CHARTS____________________________________________________ Recommended Service and Lubrication Intervals Every Every Every Every First Every 400 Lubricant Daily Hours or Hours or Hours or Hours or Hours or 12 Section Type Hours 9 Months 2 Months 3 Months 6 Months Months Air Filter...
Página 38: Common Replacement Parts
MAINTENANCE & LUBRICATION CHARTS Notes: Lubricants Indicates initial service for new machines. Manual grease gun with NLGI Grade 2 (Service ** Engine oil, oil filter and air filter may require more Class LB). frequent replacement depending operating Engine Oil - See Section 5.3 conditions.
Página 39: Notes
NOTES NOTES en-39...
Página 40: Parts Catalog
PARTS CATALOG PARTS CATALOG HOW TO USE THE PARTS CATALOG _________________________________________ Abbreviations Indented Items Indented items indicate component parts that are N/S - Not serviced separately. Can only be included as part of an assembly or another component. obtained by ordering main component or kit. These parts can be ordered separately or as part of the AR -Variable quantity or measurement is required main component.
Página 42: Guía De Inventario Sugerido
La placa del número de serie está situada en la guía del marco bajo el volante. Cushman aconseja anotar los mantenimiento, resolución de problemas y listas de números para tener a mano su referencia. piezas para su nuevo vehículo multiusos Cushman. Este manual debe guardarse con el equipo para poder consultarlo durante el funcionamiento.
Página 43 Índice SEGURIDAD 5.10 Batería ............. 22 Manipulación segura ......... 4 5.11 Recarga de la batería ........22 Avisos importantes sobre seguridad ....5 5.12 Mangueras hidraulicás ........23 5.13 Deposito y filtro hidráulico ....... 23 NÚMEROS DE IDENTIFICACIÓN 5.14 Combustible ............ 24 DEL VEHÍCULO 5.15 Sistema de combustible ........
Página 44: Seguridad
SEGURIDAD SEGURIDAD MANIPULACIÓN SEGURA __________________________________________________ ADVERTENCIA EL EQUIPO MANIPULADO INCORRECTAMENTE O POR PERSONAL NO CUALIFICADO PUEDE SER PELIGROSO. Familiarícese con la ubicación y la correcta utilización de todos los mandos. Todo operador sin experiencia debe recibir instrucciones de alguien que esté familiarizado con el equipo antes de que se le permita manipular la máquina. La seguridad depende del grado de concienciación, 13.
Página 45: Avisos Importantes Sobre Seguridad
SEGURIDAD AVISOS IMPORTANTES SOBRE SEGURIDAD __________________________________ Este símbolo de seguridad sirve para alertarle de posibles peligros. PELIGRO - Indica una situación de inminente peligro que, de no ser evitada, PROVOCARÁ la muerte o graves lesiones. ADVERTENCIA - Indica una situación potencialmente peligrosa que, de no ser evitada, PUEDE PROVOCAR la muerte o graves lesiones.
Página 46: Números De Identificación Del Vehículo
NÚMEROS DE IDENTIFICACIÓN DEL VEHÍCULO NÚMEROS DE IDENTIFICACIÓN DEL VEHÍCULO NÚMERO DE IDENTIFICACIÓN DEL VEHÍCULO ________________________________ El Número de identificación del vehículo (NIV), muestra el número de modelo, el código de fecha y el número de serie en la Placa de datos/Etiqueta de identificación que hay en el travesaño bajo el tablero de instrumentos.
Página 47: Especificaciones
ESPECIFICACIONES ESPECIFICACIONES IDENTIFICACIÓN DEL PRODUCTO ___________________________________________ 84063 ..Motor Turf Truckster diesel refrigerado por 84068..Motor Turf Truckster de gasolina refrigerado líquido, transmisión manual de 4 velocidades, por líquido, transmisión automática de 3 diferencial de 2 velocidades 11.16:1, PTO velocidades, diferencial de 2 velocidades. mecánico y ROPS de cuatro puntos.
Página 48: Vehículo
ESPECIFICACIONES VEHÍCULO _______________________________________________________________ Neumáticos Dirección ......Dirección asistida a las ruedas Delanteros: ....20 x 10 - 10 Multi Rib delanteras Traseros:....24 x 13 -12 Titan Ultra Trac Capacidad del enganche: Presión de los neumáticos: Peso máximo del Delanteros: ....1,38 Bar remolque....
Página 49: Accesorios E Información Adicional
ESPECIFICACIONES ACCESORIOS E INFORMACIÓN ADICIONAL ___________________________________ Ponerse en contacto con su Distribuidor Jacobsen para recibir una lista completa de accesorios y herramientas. PRECAUCIÓN El uso de piezas y accesorios que no sean productos autorizados por Jacobsen pueden causar lesión personal o daño al equipo y anularán la garantía.
Página 50: Declaración De Conformidad
ESPECIFICACIONES DECLARACIÓN DE CONFORMIDAD __________________________________________ DECLARATION OF CONFORMITY PROHLÁŠENÍ O SHOD OVERENSSTEMMELSESERKLÆRING CONFORMITEITSVERKLARING VASTAVUSDEKLARATSIOON VAATIMUSTENMUKAISUUSVAKUUTUS DECLARATION DE CONFORMITE KONFORMITÄTSERKLÄRUNG MEGFELEL SÉGI NYILATKOZAT DICHIARAZIONE DI CONFORMITÀ ATBILST BAS DEKLAR CIJA ATITIKTIES DEKLARACIJA DIKJARAZZJONI TAL-KONFORMITÀ DEKLARACJA ZGODNO CI DECLARAÇÃO DE CONFORMIDADE DECLARA IE DE CONFORMITATE VYHLÁSENIE O ZHODE IZJAVA O SKLADNOSTI DECLARACIÓN DE CONFORMIDAD DEKLARATION OM ÖVERENSSTÄMMELSE Business name and full address of the manufacturer Obchodní...
Página 51 ESPECIFICACIONES Harmonised standards used Použité harmonizované normy Brugte harmoniserede standarder Gebruikte geharmoniseerde standaards Kasutatud ühtlustatud standardid Käytetyt yhdenmukaistetut standardit Normes harmonisées utilisées BS EN ISO 20643 Angewandte harmonisierte Normen Harmonizált szabványok Standard armonizzati applicati BS EN ISO 5349-1 Izmantotie saska otie standarti Panaudoti suderinti standartai Standards armonizzati u ati Normy spójne powi zane Normas harmonizadas usadas BS EN ISO 5349-2 Standardele armonizate utilizate Použité...
Página 52: Ajustes
ADVERTENCIA realizadas siempre por un técnico cualificado. Si no puede realizar los ajustes correctamente, póngase en contacto con un distribuidor autorizado Cushman. Para evitar lesiones, antes de ajustar, limpiar o reparar este equipo, baje los accesorios al suelo, desconecte Cambie, no ajuste, los componentes desgastados y todos los mandos, ponga el freno de estacionamiento, dañados.
Página 53: Acceso Al Capo Delantero
AJUSTES ACCESO AL CAPÓ DELANTERO _____________________________________________ Cuando se abre el capó delantero se accede a dos paneles de acceso, el panel de fusibles, el claxon y el Tirar de la palanca depósito del cilindro principal. para liberar la lengüeta del parachoques Para abrir el capó...
Página 54: Correa Del Alternador Del Motor Diesel
AJUSTES CORREA DEL ALTERNADOR DEL MOTOR DIESEL _____________________________ Inspeccione y ajuste toda correa nueva después de las primeras 24-48 horas de funcionamiento. Posterior- mente, ajústela cada 200 horas. Ajuste la polea del alternador para que la correa se doble de 6 a 12 mm con un empuje de 9 kg en el punto medio entre la bomba del agua y las poleas del alternador.
Página 55: Correa De La Bomba Hidráulica Del Motor De Gasolina
AJUSTES CORREA DE LA BOMBA HIDRÁULICA DEL MOTOR DE GASOLINA ________________ Inspeccione y ajuste toda correa nueva después de las primeras 24-48 horas de funcionamiento. La correa se ajusta dinámicamente con un tensor de resorte a 1,3 Nm. No es necesario realizar ningún ajuste. Para quitar la correa, gire el tensor hacia el radiador para soltar tensión y saque la correa de la poleas.
Página 56: Especificacion Del Par De Torsión
AJUSTES 4.10 ESPECIFICACIÓN DEL PAR DE TORSIÓN _____________________________________ AVISO Los valores de par de torsión de estas tablas son aproximados y sólo sirven como referencia. La utilización de estos valores no es responsabilidad nuestra. Jacobsen no se hace responsable de ninguna pérdida, reclamación o daño surgido por la utilización de estas tablas.
Página 57: Mantenimiento
MANTENIMIENTO MANTENIMIENTO GENERALIDADES _________________________________________________________ Cambiar las piezas gastadas o dañadas antes de ADVERTENCIA operar la máquina. Mantener todos líquidos niveles Al objeto de evitar lesiones, antes de limpiar, ajustar o correspondientes. reparar el equipo, desactive todas las transmisiones, Mantener las protecciones en su lugar y todo el baje al suelo el grupo de herramientas de corte, ponga el equipo bien sujeto.
Página 58: Aceite De Motor
MANTENIMIENTO ACEITE DE MOTOR________________________________________________________ Compruebe el aceite del motor al inicio de cada jornada de Motor diesel: Llene el motor Kubota con aproximadamente trabajo y antes de encender el motor. 5,1 l de aceite de motor. Compruebe el nivel de aceite y añada más aceite si es necesario.
Página 59: Depósito De La Dirección Asistida
MANTENIMIENTO DEPÓSITO DE LA DIRECCIÓN ASISTIDA ______________________________________ Cuando compruebe el nivel delíquido antes de que se haya ADVERTENCIA enfriado el motor, el nivel deberá estar en la marca FRIO de la varilla. Cuando se haya calentado el motor y el líquido esté...
Página 60: Sistema De Refrigeración
MANTENIMIENTO SISTEMA DE REFRIGERACIÓN ______________________________________________ Este vehículo va equipado con un radiador, un ventilador Compruebe visualmente eldepósito controlado por temperatura, un indicador de temperatura combustible. El nivel de refrigerante deberá y una alarma de sobrecalentamiento. estar al menos en la línea LLENO pero a menos de 102 mm.
Página 61: Filtro De Aire
MANTENIMIENTO FILTRO DE AIRE __________________________________________________________ No saque el filtro para revisarlo o limpiarlo. Si se saca 5. Suelte las abrazaderas de fijación y saque el innecesariamente se incrementa el riesgo de que elemento usado lo más cuidadosamente posible y penetre polvo y demás impurezas en el motor. deséchelo.
Página 62: Batería
MANTENIMIENTO 5.10 BATERÍA ________________________________________________________________ Asegúrese de que el interruptor de encendido esté en 1. Cuando instale la batería, monte siempre el cable OFF (apagado) y que se haya retirado la llave de positivo (+) ROJO en primer lugar y el cable negativo contacto antes de poner en servicio la batería.
Página 63: Mangueras Hidraulicás
MANTENIMIENTO 5.12 MANGUERAS HIDRÁULICAS ________________________________________________ IMPORTANTE: El sistema hidráulico puede quedar permanentemente dañado si se contamina el aceite. ADVERTENCIA Antes de desconectar cualquier componente hidráulico, limpie la zona cercana a los accesorios y los extremos Para evitar heridas graves producidas por el aceite de las mangueras para limpiar de impurezas el sistema.
Página 64: Combustible
MANTENIMIENTO 5.14 COMBUSTIBLE ___________________________________________________________ Maneje el combustible con cuidado – es inflamable. Nunca llene en exceso o permita que el depósito se Utilice un contenedor adecuado de modo que la espita vacíe completamente. Compruebe nivel quepa en el cuello del tubo de llenado de combustible. Evite combustible del depósito poniendo el interruptor de la utilización de latas y embudos para transferir el encendido en la posición ON (encendido) y leyendo el...
Página 65: Presión De Los Neumáticos
MANTENIMIENTO 5.16 PRESIÓN DE LOS NEUMÁTICOS _____________________________________________ Mantenga los neumáticos correctamente inflados para 28 (193) prolongar su vida útil. Compruebe la presión de inflado con los neumáticos fríos. Inspeccione el desgaste de la pisada. 23 (159) Presión Una presión inferior ayuda a no dejar marca en céspedes de los cortos.
Página 66: Elevación Del Vehículo
MANTENIMIENTO 5.18 ELEVACIÓN DEL VEHÍCULO ________________________________________________ ADVERTENCIA Bloquear el neumático aquí Asegúrese de que el vehículo esté aparcado en una superficie llana y nivelada. Never work on a vehicle that is supported only by the jack. Always use jack stands. Siempre que sea posible, vacíe el depósito antes de levantar el vehículo.
Página 67: Remolcado Del Vehículo
MANTENIMIENTO 5.19 REMOLCADO DEL VEHÍCULO _______________________________________________ 4. Conduzca lentamente el vehículo que va a ser ADVERTENCIA remolcado hasta que la soga de remolcado esté tensada. Para evitar heridas o daños al vehículo, siga siempre 5. Durante el remolcado, intente llevar la luz de las siguiente pautas: remolcado encendida en todo momento.
Página 68: Frenos Hidráulicos
MANTENIMIENTO 5.21 FRENOS HIDRÁULICOS ____________________________________________________ La mayoría de lugarse tiene una sistema de ADVERTENCIA desechado para líquidos de freno DOT 3. Deseche el líquido correctamente. Un mantenimiento incorrecto del sistema de frenos puede provocar la pérdida de control del vehículo por parte del operador.
Página 69: Líquido Del Diferencial
MANTENIMIENTO 5.22 LÍQUIDO DEL DIFERENCIAL_________________________________________________ El líquido del diferencial debe comprobarse cada 100 horas o 3 meses. Debe cambiarse tras las primeras 100 horas y cada 600 horas (o anualmente) posteriormente. Capacidad del líquido del diferencial ....2,5 l Tapón de comprobación y de llenado Tipo de líquido ....
Página 70: Transmisión Manual Del Motor De Gasolina
MANTENIMIENTO 5.24 TRANSMISIÓN MANUAL DEL MOTOR DE GASOLINA ___________________________ El líquido de la transmisión debe comprobarse cada 100 Aplique un sellador al tapón de vaciado y vuelva a horas o 3 meses. Debe cambiarse cada 600 horas (o colocarlo. anualmente) posteriormente. Llene la transmisión con lubricante de engranajes hasta Capacidad del líquido que el líquido salga por el orificio.
Página 71: Sistema Eléctrico
MANTENIMIENTO 5.26 SISTEMA ELÉCTRICO ______________________________________________________ Motor diesel PRECAUCIÓN Panel de instrumentos, 20 A Puerto eléctrico 15 A bomba de combustible Apague siempre el motor y desconecte el cable y encendido Luz de freno, negativo de la batería (negro) antes de revisar o Accesorio 10 A 10 A...
Página 72: Cambio De Los Faros Delanteros
MANTENIMIENTO Ajuste del interruptor DIP del tacómetro: Usando un destornillador pequeño o algo similar, empuje las palancas del interruptor hacia arriba o abajo para que El panel de instrumentos usa un código secuencial de coincidan con el código secuencial de esta máquina. interruptor DIP para identificar el número de impulsos de entrada por revolución del motor y tipo de motor para Ajuste del conmutador...
Página 73: Comprobación De Diagnósticos Efi
MANTENIMIENTO 5.30 COMPROBACIÓN DE DIAGNOSTICOS EFI _____________________________________ Sólo unidades con motor Suzuki de gasolina Abra el capó delantero y localice el conector OBD-II en la abrazadera del depósito de líquido de frenos. Conecte El sistema eléctrico va equipado con un conector de un lector OBD-II en el conector, ponga el interruptor de diagnóstico OBD-II.
Página 74: Almacenamiento
MANTENIMIENTO 5.32 ALMACENAMIENTO _______________________________________________________ Generalidades Tras el almacenamiento Lave el tractor a fondo y lubríquelo. Repare y pinte el Compruebe y reinstale la batería. metal dañado o desnudo. Compruebe o instale un nuevo filtro de combustible y Inspeccione el tractor, apriete todos los elementos, un limpiador de aire.
Página 75: Resolución De Problemas
RESOLUCIÓN DE PROBLEMAS RESOLUCIÓN DE PROBLEMAS GENERALIDADES _________________________________________________________ El siguiente cuadro indica los problemas básicos que eléctrico, póngase en contacto con el distribuidor de pueden surgir durante el arranque y la operación. Para Jacobsen local. obtener una información más detallada sobre el sistema Síntomas Posibles causas Acción...
Página 76: Cuadros De Mantenimientoy Lubricación 7.1 Generalidades
CUADROS DE MANTENIMIENTO Y DE LUBRICACIÓN CUADROS DE MANTENIMIENTO Y DE LUBRICACIÓN GENERALIDADES _________________________________________________________ 2. Utilice grasa cumpla supere ADVERTENCIA especificaciones NLGI Grado 2 LB. Aplique grasa con una pistola manual y llene despacio hasta que la grasa comience a subir. No utilice pistolas de aire Antes de limpiar, ajustar o reparar este equipo comprimido.
Página 77: Cuadro De Mantenimiento
CUADROS DE MANTENIMIENTO Y DE LUBRICACIÓN CUADRO DE MANTENIMIENTO ______________________________________________ Intervalos de Servicio y de Lubricación Recomendados Cada Cada Cada Cada Cada Primeras Tipo de Diaria- 75 horas lubri- mente horas o horas o horas o horas o sección horas cante meses 3 meses...
Página 78: Piezas De Recambio Habituales
CUADROS DE MANTENIMIENTO Y DE LUBRICACIÓN Notas: Lubricantes: * Indica el servicio inicial para máquinas nuevas. Pistola Manual con grasa NLGI de Grado 2 ** Dependiendo de las condiciones de funcionamiento, es (Servicio Clase LB). posible que haya que cambiar con más frecuencia el aceite Aceite Motor –...
Página 79: Notas
NOTAS NOTAS es-39...
Página 80: Catálogo De Piezas
CATÁLOGO DE PIEZAS CATÁLOGO DE PIEZAS CÓMO USAR EL CATÁLOGO DE PIEZAS ______________________________________ Abreviaciones Artículos seleccionados Los artículos con una marca de sangría indican las N/S - No revisado por separado, sólo se puede piezas de componentes incluidas como parte de una obtener pidiendo el componente principal o el unidad u otro componente.
Página 81 PARTS CATALOG TABLE OF CONTENTS______________________________________________________ 1.1 ..Front Body ............42 58.1..Gas Engine Schematic ........160 2.1 ..Engine Cover ............. 44 59.1..Diesel Engine Electrical Schematic ....162 3.1 ..Four Post ROPS ..........46 4.1 ..Upper ROPS ............48 5.1 ..
Página 82: Front Body
TURF TRUCKSTER Serial No. All 1.1 Front Body ® By Jacobsen 4158740 Turf Truckster Turf Truckster ® ® ® ® By Jacobsen By Jacobsen 4158742 4158741 30 / 31 FUSE PANEL FUSE PANEL POWER INS PANEL RADIATOR POWER INS PANEL POINT FUEL RELAY POINT...
Página 83: Gas Engine Schematic
Lockwasher, 1/4 in. Shakeproof 2703158 Decal, Fuses Diesel Engine 4117221 Decal, Fuses Gas Engine 473142 Cable Tie, 15-1/2 in. 4158740 Decal, Cushman 4158741 Decal, Left Side Turf Truckster 4158742 Decal, RIght Side Turf Truckster 38541 Tube, Clear Document 38061A Cap, Vinyl 840508...
Página 84: Engine Cover
TURF TRUCKSTER Serial No. All 2.1 Engine Cover Vehicles with Four Post ROPS Engine Cover Lock 1.4 2.6 8.3 11.3 16.1 1600 7.1 10.0 1.5 2.9 9.3 12.8 18.1 1800 7.9 11.3 1.7 3.2 5.5 10.4 14.2 20.1 2000 8.8 12.5 1.9 3.5 6.1 11.4 15.6 22.1 2200...
Página 85 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 306328 Cotter Pin, 3/32 x 3/4 in. 308090 Washer, 1/4 450452 Nut, M6-1 Hex Flange 450453 Nut, M8-1.25 Hex Flange Decal, Emission Gas Units 893541 Handold, Right Side 450541 Screw, M6-1 x 16 mm Hex Flange 452388 Screw, M8-1.25 x 20 mm Hex Flange 4139724...
Página 86: Four Post Rops
TURF TRUCKSTER Serial No. All 3.1 Four Post ROPS WARNING This structure's proctective capability may be impaired by structural damage, overturn, or alteration. If any of these conditions occur, this structure must be replaced. WARNING Use seat belt Engine Cover Control Console...
Página 87 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4205580 Four Post ROPS • Decal, ROPS Warning 800547 • Screw, M10-1.25 x 20 mm Hex Head 452410 • Screw, M12-1.75 x 30 mm Flange 450455 • Nut, M12-1.75 Hex Flange 4140269 •...
Página 88: Upper Rops
WARNING PART NUMBER: 893146 Meets SAE: J1040 MAY94 Only to be used on Cushman truck models The protection offered by this ROPS will be impaired if it has with matching lower structure been subjected to any modification or structural damage.
Página 89 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4184320 Upper ROPS 4175340 • Decal, Warning and ROPS Cert. 844988 Foam, 1/2 in. Perforated ROPS 452411 Screw, M12-1.75 x 40 mm Flange 450455 Nut, M12-1.75 Hex Flange 4140269 Seat Belt Assembly •...
Página 90: Throttle Control
TURF TRUCKSTER Serial No. All 5.1 Throttle Control WARNING Failure to follow this warning can cause severe personal injury or death. This vehicle is designed and constructed for OFF-ROAD USE ONLY. Do not use this vehicle on any public roadway where automobiles or other motor vehicles are present.
Página 91 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 841663 Panel, Floor Access 800943 Screw, #10-14 x 5/8 in. Self Tapping 894159 Pedal, Throttle 524633 Bolt, 5/16-18 x 1 in. Shoulder 524643 Bearing, Split 548911 Nut, 5/16-18 Flange 2703257.7 Bracket, Foot Throttle 452378 Screw, M6-1 x 20 mm Flange 450452...
Página 92: Control Console
TURF TRUCKSTER Serial No. All 6.1 Control Console 4 / 5 845185 W ARNIN G P A R K I N G B R A K E S A R E N O T A U T O - M A T I C A L LY A P P L I E D . V E H I C L E M AY M O V E C A U S I N G P E R S O N A L I N J U R Y A N D / O R P R O P E R T Y D A M A G E .
Página 93 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 2700796 Console Used on all, except 84064 2700797 Console, EC Used on 84064 Only 844177 • Decal, Aux. Transmission 844179 • Decal, Hydraulic Controls 822819 • Decal, Parking Brake Used on all, except 84064 845185 •...
Página 94: Parking Brake And High-Low Speed Control
TURF TRUCKSTER Serial No. All 7.1 Parking Brake and High-Low Speed Control...
Página 95 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4202860 Lever, Parking Brake 845134 Bracket, Parking Brake Lever 452388 Screw, M8-1.25 x 20 mm Flange 452391 Screw, M8-1.25 x 40 mm Flange 450453 Nut, M8-1.25 Flange 845133 Cable, Parking Brake 450377 Nut, M6-1 Staytite 827182...
Página 96: Brake Pedal
TURF TRUCKSTER Serial No. All 8.1 Brake Pedal Route both hoses through opening in front clip Lower ROPS Pedal Mounting View Rotated 90 Degrees for Clarity Route front brake tube through opening in front clip Route rear brake Left Frame Rail tube under floor access panel Tube Routing...
Página 97 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 2701737.7 Bracket, Master Cylinder 892921 Pedal, Brake 840726 Bearing, Brake Pivot 840725 Tube, Brake Pivot 842935 Tab, Locking 452388 Screw, M8-1.25 x 20 mm Flange 450453 Nut, M8-1.25 Flange 895113 Master Cylinder 800930 Screw, M8-1.25 x 16 mm Flange 894167...
Página 98: Clutch Pedal Linkage
TURF TRUCKSTER Serial No. 84063 All 9.1 Clutch Pedal Linkage Serial No. 84064 All Serial No. 84067 All Serial No. 84069 All Lower ROPS Diesel Units Cable Routing View Rotated 90 Degrees for Clarity View Rotated 90 Degrees for Clarity Gas Units Diesel Units...
Página 99 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 892933 Pedal, Clutch 840726 Bearing, Brake Pivot 844611 Spring, Torsion 840725 Tube, Pedal Pivot 842935 Tab, Locking 452388 Screw, M8-1.25 x 20 mm Flange 450453 Nut, M8-1.25 Flange 894308 Switch, Clutch Micro 450510 Screw, M3-0.5 x 20 mm Pan Head 452424...
Página 100: Manual Transmission Shifter Linkage
TURF TRUCKSTER Serial No. 84063 All 10.1 Manual Transmission Shifter Linkage Serial No. 84064 All Diesel Units 21 22 Diesel Unit Cable Attachment Shifter Mounting and Cable Routing View Rotated 90 Degrees for Clarity...
Página 101 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 800582 Screw, 1/4-20 x 3/4 in. Truss Head Diesel Units 2703956.7 Mount, Shifter 2703953 Selector, Gear 842773 Rod End, 1/2-20 308091 Flat Washer, 1/2 311763 Screw, 1/2-20 x 2-1/4 in. Hex Head 843679 Plate, Wear 452692...
Página 102 TURF TRUCKSTER Serial No. 84067 All 11.1 Manual Transmission Shifter Linkage Serial No. 84069 All Gas Units Shifter Mounting and Cable Routing View Rotated 90 Degrees for Clarity Gas Unit Cable Attachment...
Página 103 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4146819 Retaining Ring M6 4142630 Mount, Shifter 4142627 Selector, Gear 842773 Rod End, 1/2-20 308091 Flat Washer, 1/2 311763 Screw, 1/2-20 x 2-1/4” Hex Head 843679 Plate, Wear 452692 Screw, M6-1 x 12 mm Self Tap 604174 Flat Washer, 3/8”...
Página 104: Automatic Transmission Shifter
TURF TRUCKSTER Serial No. 84068 All 12.1 Automatic Transmission Shifter Item Part No. Qty. Description Serial Numbers/Notes 103867 Flat Washer, 5/16 302030 Screw, 1/4-20 x 1-1/4 in. 306375 Nut, 1/4-20 Hex 306396 Lockwasher, 1/4 800582 Screw, 1/4-20 x 3/4 in. 821164 Hair Pin, 1/4 x 1-1/8 in.
Página 105: Automatic Transmission Oil Cooler
TURF TRUCKSTER Serial No. 84068 All 13.1 Automatic Transmission Oil Cooler Item Part No. Qty. Description Serial Numbers/Notes 838340 Oil Cooler 800789 Kit, Oil Cooler Mounting 826590 Hose, 5/16 I.D. 821893 Trim, Push On Not Shown 809231 Grommet 825624 Hose Clamp >...
Página 106: Frame Attachments
TURF TRUCKSTER Serial No. All 14.1 Frame Attachments...
Página 107 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Front Suspension See 17.1, 18.1 and 19.1 452415 Screw, M12-1.75 x 80 mm Flange 450455 Nut, M12-1.75 Hex Flange 4243009 Wheel and Tire, Straight Rib 4243005 • Rim, 10.00 x 7 in. Five Bolt 3.94 in.
Página 108: Frame, Lower Rops And Platform
TURF TRUCKSTER Serial No. All 15.1 Frame, Lower ROPS and Platform 2703961 90 KG 680 KG Gas Engine and Transmission Mounts...
Página 109 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Frame, Main 4 Wheel Standard Frame, Painted Black Frame, Galvanized Main 4 Wheel Optional Galvanized Frame 893145.7 ROPS, Lower 893199.7 Platform, Truckster Standard Platform, Painted Black 893199G02 Platform, Galvanized Truckster Optional Galvanized Platform 893525G01 Support, Platform 452406...
Página 110: Rear Axle
TURF TRUCKSTER Serial No. All 16.1 Rear Axle Gas Units Diesel Units 21 / 22...
Página 111 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 894825 11.16:1 Rear Differential Assembly 84063, 84064 and 84069, See 44.1 894826 14.21:1 Rear Differential Assembly 84067 and 84068, See 44.1 800198 Locknut, 1/2-20 809180 Flat Washer, 1/2 893862 Spring, Leaf 843238 •...
Página 112: Front Control Arms
TURF TRUCKSTER Serial No. All 17.1 Front Control Arms...
Página 113 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4120138 Frame, 4 Wheel Steering 893266 Upper Control Arm 893233 Left Side Lower Control Arm 893234 Right Side Lower Control Arm 844148 Upper Ball Joint • Boot • Boot Retainer • Screw, 5/16-24 x 1 in. Hex Head Black Oxide Finish, Grade 8 •...
Página 114: Steering Linkage
TURF TRUCKSTER Serial No. All 18.1 Steering Linkage...
Página 115 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 841255 Steering Gear 305134 • Nut, 7/8-14 Hex Jam 308008 • Lockwasher, 7/8 841336 Arm, Pitman 894635 Strut Assembly 800945 Screw, M12-1.75 x 60 mm Hex Head 450455 Nut, M12-1.75 Hex Flange Grade 10.9 311392 Screw, 7/16-14 x 2 in.
Página 116: Front Brakes
TURF TRUCKSTER Serial No. All 19.1 Front Brakes...
Página 117 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 2702257.7 Front Hub Includes cup portion of Items 3 & 4 800908 • Bolt, M12-1.5 x 42 mm Wheel 500534 Outer Bearing Cup and Cone 500596 Inner Bearing CUp and Cone 2702217 Tube, Left Front Brake 841839...
Página 118: Steering Column
TURF TRUCKSTER Serial No. All 20.1 Steering Column Lower ROPS 23 / 24 Power Steering Hose Routing...
Página 119 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 893571 Tube, Steering Mount 800930 Screw, M8-1.25 x 16 mm Flange 306799 Lockwasher, 5/16 External Tooth 450453 Nut, M8-1.25 Flange 893344 Shaft, Steering 887259 Bearing Assembly 828590 • Housing, Bearing 808060 •...
Página 120: Diesel Radiator
TURF TRUCKSTER Serial No. 84063 All 21.1 Diesel Radiator Serial No. 84064 All 840754 009034880...
Página 121 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 843862 Tube, 1/4 in. I.D. Clear Vinyl 10 Foot Length, Cut to 12 in. 835805 Hose, Radiator Overflow 452006 Flat Washer, 5/16 446134 Lockwasher, 5/16 443106 Nut, 5/16-18 Hex 450452 Nut, M6-1 Hex Flange 450541 Screw, M6-1 x 16 mm Hex Flange 452378...
Página 122: Gas Radiator
TURF TRUCKSTER Serial No. 84067 All 22.1 Gas Radiator Serial No. 84068 All Serial No. 84069 All...
Página 123 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 843862 Tube, 1/4 in. I.D. Clear Vinyl 10 Foot Length, Cut to 12” 835805 Hose, Radiator Overflow 452006 Flat Washer, 5/16 446134 Lockwasher, 5/16 443106 Nut, 5/16-18 Hex 450452 Nut, M6-1 Hex Flange 450541 Screw, M6-1 x 16 mm Hex Flange 452378...
Página 124: Diesel Engine And Transmission Mounting
TURF TRUCKSTER Serial No. 84063 All 23.1 Diesel Engine and Transmission Mounting Serial No. 84064 All...
Página 125 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Engine and Clutch See 26.1 4192125 Frame, Engine Mount Mount, Engine See 14.1, Left shown, right similar 306836 Screw, 3/8-16 x 2-1/4 in. Hex Head 306981 Flat Washer, 3/8 841885 Mount, Engine Isolation 809174 Washer, Isolator 120177...
Página 126: Gas Engine And Mt Mounting
TURF TRUCKSTER Serial No. 84067 All 24.1 Gas Engine and MT Mounting Serial No. 84069 All...
Página 127 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Engine Assembly See 27.1 Manual Transmission Order with engine 4140899 Plate, Clutch Housing 2702548 Clutch Disc and Pressure Plate Set 4117900 • Pressure Plate Limited Availability 2702547 Screw, M8-1.25 x 16 mm Lockwasher 2702688 Stud, M10-1.25 x 65 mm 2702687...
Página 128: Gas Engine And At Mounting
TURF TRUCKSTER Serial No. 84068 All 25.1 Gas Engine and AT Mounting...
Página 129 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Engine Assembly See 27.1 4148212 Automatic Transmission 4140900 Plate, Transmission Housing 4148213 Torque Converter 4120097 Plate, Drive 4148065 Screw, M8-1.25 x 9.5 mm Flange 2702688 Stud, M10-1.25 x 65 mm 2702686 Screw, M10-1.25 x 55 mm Flange 2702756 Screw, M10-1.25 x 50 mm Flange...
Página 130: Diesel Engine And Clutch
TURF TRUCKSTER Serial No. 84063 - 1651~xxxx 26.1 Diesel Engine and Clutch Serial No. 84064 - 1651~xxxx...
Página 131 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4173201 Engine, Kubota D1105 E3B 4113986 • Engine Oil Filter 4183623 • Alternator 4174200 Bracket, Hydraulic Pump 4174440 Mount, Right Side Engine 800547 Screw, M10-1.25 x 20 mm Flange 303269 Lockwasher, 7/16 887994 Pump, Hydraulic See 40.1...
Página 132 TURF TRUCKSTER Serial No. 84063 - xxxx and Up 26.2 Diesel Engine and Clutch Serial No. 84064 - xxxx and Up...
Página 133 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4173201 Engine, Kubota D1105 E3B 4113986 • Engine Oil Filter 4183623 • Alternator 4174200 Bracket, Hydraulic Pump 4209665 Mount, Right Side Engine 800547 Screw, M10-1.25 x 20 mm Flange 303269 Lockwasher, 7/16 887994 Pump, Hydraulic See 40.1...
Página 134: Suzuki Gas Engine
TURF TRUCKSTER Serial No. 84067 All 27.1 Suzuki Gas Engine Serial No. 84068 All Serial No. 84069 All 17 18 14 (84067 and 84068) 21 (84069)
Página 135 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Suzuki K6 Engine See Engine Parts Manual 2701908 • Oil Filter 4140919 • Belt, Water Pump and Alternator 4120017 • Right Side Engine Mount 4140905 • Bolt, RIght Side Engine Mount 4120018 •...
Página 136: Diesel Engine Speed Control
TURF TRUCKSTER Serial No. 84063 All 28.1 Diesel Engine Speed Control Serial No. 84064 All...
Página 137 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 2703683 Throttle Cable See 5.1 for other end of cable 844130 Cable, Governor Control See 5.1 for other end of cable 4174720 Bracket, Throttle 4174662 Lever, Governor 835271 Nut, 1/4-20 Lever Pivot 130728 Nut, 1/4-20 Hex Jam 840473...
Página 138: Diesel Engine Air Filter
TURF TRUCKSTER Serial No. 84063 All 29.1 Diesel Engine Air Filter Serial No. 84064 All...
Página 139 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 601585 Box, Air 452405 Screw, M10-1.5 x 80 mm Hex Flange 450454 Nut, M10-1.5 Hex Flange 36092-G01 Hose, 2 in. x 16 in. High Temp Air 11391G7 Clamp, Hose 3001965 Air Filter 5000919 •...
Página 140: Diesel Engine Exhaust And Remote Oil Filter
TURF TRUCKSTER Serial No. 84063 All 30.1 Diesel Engine Exhaust and Remote Oil Filter Serial No. 84064 All Tailpipe Outlet to be parallel to ground. View Rotated 180°...
Página 141 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Kubota Engine See 26.1 553020 • Gasket, Exhaust 4183634 • Head, Remote Filter 4113986 • Engine Oil Filter 4190701 Fitting, 90° 4174290 Bracket, Remote FIlter 800547 Screw, M10-1.25 x 20 mm Hex Head 303269 Lockwasher, 7/16 306325...
Página 142: Gas Engine Governor Linkage
TURF TRUCKSTER Serial No. 84067 All 31.1 Gas Engine Governor Linkage Serial No. 84068 All Serial No. 84069 All...
Página 143 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4139208 Plate, Governor 4141031 Bolt, Intake Manifold Included with Engine 306396 Lockwasher, 1/4 308090 Flat Washer, 1/4 845224 Plug, Tube 11391G4 Clamp, 1/4 in. to 5/8 in. Worm Drive 4144145 Plug, 3/8 x 1 in. Tube 2700540 Lever, Governor 2700859...
Página 144: Gas Engine Governor
TURF TRUCKSTER Serial No. 84067 All 32.1 Gas Engine Governor Serial No. 84068 All Serial No. 84069 All...
Página 145 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4141425 Governor 111812 • Yoke, Spool 111814 • Washer, Thrust 359864 • Washer, Thrust 111817 • Spool, Governor 112840 • Bearing, Thrust 130728 • Nut, 1/4-20 Hex Jam 111813 • Seal, Shaft 160410 •...
Página 146: Gas Engine Air Filter
TURF TRUCKSTER Serial No. 84067 All 33.1 Gas Engine Air Filter Serial No. 84068 All Serial No. 84069 All...
Página 147 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Engine Assembly See 27.1 842915 Bracket, Air Filter 452389 Screw, M8-1.25 x 25 mm Hex Flange 450453 Nut, M8-1.25 Hex Flange 4118027 Air Filter 5000913 • Element, AIr Filter 5000914 • Vactuator Valve 4139211 Hose, Engine Air Intake 4140617...
Página 148: Gas Engine Remote Oil Fill
TURF TRUCKSTER Serial No. 84067 All 34.1 Gas Engine Remote Oil Fill Serial No. 84068 All Serial No. 84069 All Item Part No. Qty. Description Serial Numbers/Notes 4188041 Bracket, Valve Cover 548971 Screw, 5/16-18 x 5/8” Hex Flange 4148202 Cap, Oil FIll Included with Engine 843420 O-Ring...
Página 149: Gas Engine Exhaust
TURF TRUCKSTER Serial No. All 35.1 Gas Engine Exhaust Tailpipe outlet to be parallel to ground. Item Part No. Qty. Description Serial Numbers/Notes 4233161 Muffler 4232042 Catalytic Converter 2702502 Bolt, Muffler Flange 2702501 Spring, Muffler Flange 838295.8 Strap, Muffler Hanger 450193 Screw, M8-1.25 x 30 mm Hex Head 64237-05...
Página 150: Diesel Fuel System
TURF TRUCKSTER Serial No. 84063 All 36.1 Diesel Fuel System Serial No. 84064 All...
Página 151 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 826590 Hose, Fuel Tank to Fuel Pump 5/16 in. 25 Foot Roll, Cut to 10 in. 4113022 Clamp, Hose 826590 Hose, Fuel Return 25 Foot Roll, Cut to 21-1/2 in. 826590 Hose, Pump to Fuel Filter 5/16 in.
Página 152: Gas Fuel System
TURF TRUCKSTER Serial No. 84067 All 37.1 Gas Fuel System Serial No. 84068 All Serial No. 84069 All CONNECT TO FUEL INJECTOR RAIL CONNECT TO REAR FACING PORT ON INTAKE MANIFOLD...
Página 153 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4218621 Hose, Fuel Tank to Adapter 5/16 in. 6 Ft. Length, Cut to 14 in. 830930 Clamp, Hose 4218622 Hose, Adapter to Pump 7/16 in. 6 In. Length, Cut to 3 in. 4218621 Hose, Pump to Fuel Filter 5/16 in.
Página 154 TURF TRUCKSTER Serial No. 84067 All 38.1 Gas Fuel System Serial No. 84068 All Serial No. 84069 All Right Frame Rail...
Página 155 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4166842 Fuel Tank AY 843726 • Tube, Fuel Pick Up 4166841 • Elbow, 90 1/4 361117 • Bushing 4170840 • Rollover Valve 4168131 • Grommet, Fuel Tank 4166840 Cap, Unvented Fuel Ratchet 843298 Sender, FuelTank 829954...
Página 156: Hydraulic Tank And Filter
TURF TRUCKSTER Serial No. All 39.1 Hydraulic Tank and Filter NOTE: PREVENT HYDRAULIC SYSTEM DAMAGE H O S E R E M O V E D F R O M A C C E S S O R Y M U S T B E C L E A N E D A N D P L U G G E D I N T O R E T U R N P O R T T O P R E V E N T D A M A G E D U E T O A C C -...
Página 157 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 894675G01 Tank, Hydraulic 452388 Screw, M8-1.25 x 20 mm Flange 450453 Nut, M8-1.25 Hex Flange 452399 Screw, M10-1.5 x 25 mm Flange 800113 Plug, 1/2 NPT 893539 Dipstick, Hydraulic Tank 827486 Valve, Pressure Relief Battery, 12 Volt 844601...
Página 158: Hydraulic Pump And Filter
TURF TRUCKSTER Serial No. All 40.1 Hydraulic Pump and Filter...
Página 159 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 844564 Hose, Tank to Filter 836206 Clamp, Hose 844583 Fitting, 90° 844566 Fitting, Straight 844628 Hose, Pump to Selector Valve 844652 Fitting, 9/16-18 x 3/4-16 Straight 844600 Hose, Selector Valve to Coupler 844571 Fitting, 9/16-18 x 3/4-16 90°...
Página 160: Lift Cylinder Circuit
TURF TRUCKSTER Serial No. All 41.1 Lift Cylinder Circuit Lift Cylinder Mounting...
Página 161 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 882993 Cylinder, Dump Box 883236 • Seal Kit Texas Hydraulics 884574 • Seal Kit Columbus Hydraulics 886001 • Seal Kit DANA Hydraulics 830810 Pin, Clevis 809265 Hair Pin 821893 Trim, Push On 817320 Clamp, Hose 452378...
Página 162: Diesel Electrical Components
TURF TRUCKSTER Serial No. 84063 All 42.1 Diesel Electrical Components Serial No. 84064 All Item 8 Routing Engine Harness G r ound Wire s...
Página 163 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 450452 Nut, M6-1 Hex Flange 452378 Screw, M6-1 x 20 mm Hex Flange 2701465 Solenoid, Starter 120052 • Lockwasher, #10 2702244 • Nut, #10-32 Hex 306325 • Lockwasher, 5/16 443106 • Nut, 5/16-18 Hex 4244442 Bracket, Horn, Brake Fluid Reservior Screw, #10-16 x 3/4 in.
Página 164: Gas Electrical Components
TURF TRUCKSTER Serial No. 84067 All 43.1 Gas Electrical Components Serial No. 84068 All Serial No. 84069 All Item 8 Routing Engine Harness Ground Wires Black Wires Wires...
Página 165 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 450452 Nut, M6-1 Hex Flange 450544 Screw, M6 x 30 mm Pan Head 2701464 Solenoid, Starter 120052 • Lockwasher, #10 2702244 • Nut, #10-32 Hex 306325 • Lockwasher, 5/16 443106 • Nut, 5/16-18 Hex 4244442 Bracket, Horn, Brake Fluid Reservior 800943...
Página 166: Differential Assembly
TURF TRUCKSTER 44.1 Differential Assembly Serial No. All Part Number 894826 (14.21:1 Differntial) Part Number 894825 (11.16:1 Differential)
Página 167 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 894826 Differential Assembly 14.21:1 Differential 894825 Differential Assembly 11.16:1 Differential 891829 • Differential Housing See 45.1 • Axle Tubes and Shafts See 46.1 • Input, Main and Jack Shaft See 48.1 •...
Página 168: Differential Housing
TURF TRUCKSTER Serial No. All 45.1 Differential Housing Part Number 891829...
Página 169 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 891829 Differential Housing • Bearing Caps 306829 • Screw, 7/16-14 x 2 in. Hex Head 103867 • Flat Washer, 5/16 111074 • Plug, Drain 111758 • Stud, 3/8-16 & 3/8-24 x 1-23/32 306416 •...
Página 170: Axle Tubes And Shafts
TURF TRUCKSTER Serial No. All 46.1 Axle Tubes and Shafts...
Página 171 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 894826 Differential Assembly 14.21:1 Differential 894825 Differential Assembly 11.16:1 Differential 2702535.7 • Tube, Right Side Axle 2702534.7 • Tube, Left Side Axle 2700530 • Left Side Axle Assembly 2700514 • • Shaft, Left Side Axle 845356 •...
Página 172: Front And Shifter Cover
TURF TRUCKSTER 47.1 Front and Shifter Cover Serial No. All 14.21:1 Differential (894826) 11.16:1 Differential (894825) 11 / 12...
Página 173 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 836431 Cover, Front 306322 Screw, 5/16-18 x 7/8 in. Hex Head 103867 Flat Washer, 5/16 307776 Screw, 3/8-16 x 2-3/4 in. Hex Head 810437 Clamp, 1/2 in. P 14.21:1 Differential Only 810435 Clamp Right Side Brake Tube...
Página 174: Input, Main And Jack Shafts
TURF TRUCKSTER 48.1 Input, Main and Jack Shafts Serial No. All 14.21:1 Differential (894826) 11.16:1 Differential (894825)
Página 175 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 836421 Shaft, Input 836693 Bearing, Ball 809254 Ring, External Retaining 800695 Ring, External Retaining 800737 Ring, Internal Retaining 837020 Baffle, Vent 812335 Seal, Oil 4184901 Shaft, Main 812009 Bearing, Ball 836429 Collar, Engaging 844956 Bearing, Bronze Thrust...
Página 176: Transmission Clutch Release-Shift Selector 136 50.1
TURF TRUCKSTER Serial No. 84063 - All 49.1 Transmission Clutch Release-Shift Selector Serial No. 84064 - All Diesel Engine Only...
Página 177 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes Transmission Case See 50.1 Shift Assembly See 52.1 845223 Gasket, Shift Case 2702659 Screw, M8-1.25 x 40 mm 01550-08553 Screw, M8-1.25 x 55 mm 23265-85200 Bearing, Clutch Release 09205-03019 Roll Pin 2702684 Plug, Drain 11741-85200...
Página 178: Transmission Case
TURF TRUCKSTER Serial No. 84063 - All 50.1 Transmission Case Serial No. 84064 - All Diesel Engine Only...
Página 179 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 24700-85200 Case, Transmission Upper and Lower Half 2702690 • Pin, Alignment 2702665 • Screw, M8-1.25 x 120 mm Flange 2702470 • Screw, M8-1.25 x 30 mm Flange 2702659 • Screw, M8-1.25 x 40 mm Flange 2702471 •...
Página 180: Input And Main Shaft
TURF TRUCKSTER Serial No. 84063 - All 51.1 Input and Main Shaft Serial No. 84064 - All...
Página 181 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 24110-80410 Shaft, Input 4th Gear 2702561 Bearing, Needle 4141037 Bearing, Input Shaft Ball 09380-28007 Cir Clip 24410-83000 High Speed Syncroniser Includes Hub and Sleeve 24471-60A00 Key, Syncronizer 2703581 Spring, High Speed Syncronizer 24432-83001 Ring, Syncronizer 2703453...
Página 182: Gear Shift Fork Linkage
TURF TRUCKSTER Serial No. 84063 - All 52.1 Gear Shift Fork Linkage Serial No. 84064 - All...
Página 183 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 25411-85201 Shaft, Low Speed Fork 1st and 2nd Gear 25420-85201 Shaft, High Speed Fork 3rd and 4th Gear 25451-85261 Shaft, Reverse Fork Reverse 06111-12004 Ball 25415-83000 Spring, Detent 09261-03017 Roller 2703699 Fork, Low Gear Shift 1st and 2nd Gear 2703699...
Página 184: Mechanical Pto
TURF TRUCKSTER Serial No. 84063 - All 53.1 Mechanical PTO Serial No. 84064 - All Diesel Units Only...
Página 185 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 845257 Housing, Mechanical PTO Bushing, Output Shaft 2700121 Gasket, PTO Housing to Trasmission 2700120 Gasket, Bearing Housing 894989 Housing, Bearing 844188 • Seal, Oil 815093 • Bearing, Ball 452389 Screw, M8-1.25 x 25 mm Flange 844185 Shaft, PTO Output 815182...
Página 186: Diesel Engine Main Harness
TURF TRUCKSTER Serial No. 84063 - All 54.1 Diesel Engine Main Harness Serial No. 84064 - All Part Number 894266 Engine Harness Engine Harness Connector #1 Connector #2 Engine Harness Connector Engine Harness (Gas Only) Connector #3 Cab Stop Light (Option) Flasher Jumper Plug...
Página 187 TURF TRUCKSTER Item Part No. Qty. Description Serial Number / Notes 825973 Connecter, Six Male Terminal 825886 Terminal, 1/4 in. Male 14-16 Gauge Single Wire 825961 Terminal, 1/4 in. Male 10 Gauge Two Wire 829630 Connector, Four Female Terminal 825748 Terminal, 1/4 in.
Página 188: Diesel Engine And Fan Harness
TURF TRUCKSTER Serial No. 84063 - All 55.1 Diesel Engine and Fan Harness Serial No. 84064 - All Part Numbers 4174321, 4179800, and 4179801 Starter Oil Pressure Switch Ground Wires Parking Brake Glow Plug Starter Fuel Solenoid Solenoid Fuel Shutoff Relay Engine Harness Connector #1...
Página 189 TURF TRUCKSTER Item Part No. Qty. Description Serial Numbers/Notes 4174321 Engine Harness 825877 • Connector, Six Female Terminal 825748 • Terminal, 1/4 in. Fem. 14-16 Gauge Single Wire 825878 • Terminal, 1/4 in. Fem. 10 Gauge Two Wire 829630 • Connector, Four Male Terminal 825961 •...
Página 190: Gas Main Harness
TURF TRUCKSTER Serial No. 84067 - All 56.1 Gas Main Harness Serial No. 84068 - All Serial No. 84069 - All Part Number 4238042 AT/MT Engine Speed Harness Connectors Shift Sensor Back-Up Solenoid Switch 17” Connector Shift Switch 10” 6” 20”...
Página 191 TURF TRUCKSTER Item Part No. Qty. Description Serial Number / Notes 825973 Connecter, Six Male Terminal 825886 Terminal, 1/4 in. Male 14-16 Gauge Single Wire 825961 Terminal, 1/4 in. Male 10 Gauge Two Wire 829631 Connector, Four Female Terminal 825748 Terminal, 1/4 in.
Página 192: Gas Main Harness (Continued)
TURF TRUCKSTER Serial No. 84067 - All 56.1 Gas Main Harness (Continued) Serial No. 84068 - All Serial No. 84069 - All Part Number 4238042 AT/MT Engine Speed Harness Connectors Shift Sensor Back-Up Solenoid Switch 17” Connector Shift Switch 10” 6”...
Página 193 TURF TRUCKSTER Item Part No. Qty. Description Serial Number / Notes 826192 Tubing, 3/4 in. I.D. Black Convoluted 25 Foot Bulk 826193 Tubing, 7/16 in. I.D. Green Convoluted 25 Foot Bulk Connector, 12 Contact Male MT Engine Harness Connector 833257 Terminal, Female 838463 Seal, Wire...
Página 194: Gas Engine Electrical Schematic
TURF TRUCKSTER Serial No. 84067 All 57.1 Gas Engine Electrical Schematic Serial No. 84068 All Serial No. 84069 All See page 158 for Engine Harness 60 pin connector Bn/ Y e Gn/Wh Bk/Rd Wh/Rd Wh/Rd Bk/Bn Bk/Wh Rd/Gn Connector Pins 1 - 3, 7-13, Gn/Wh and 16 Not Used.
Página 195 TURF TRUCKSTER Gn/Bk Bk/Wh Shifter Rd/Ye Bk/Wh Light 25 A Bk/Wh Bk/Wh Rd/Bk Wh/Rd 15 A Rd/Og Bn/Ye Bn/Ye 10 A Gn/Bk Gn/Wh Gn/Wh 10 A Bk/Rd Motor Wh/Rd Relay Bk/Rd Rd/Gn Rd/Gn Bk/Gn Bk/Gn Fuel Pk/Bu Pk/Bu Fuel Pump Relay Bk/Wh Wh/Pk...
Página 196 TURF TRUCKSTER Gn/Bk Bk/Wh Bk/Wh Bk/Wh Bk/Wh Bk/Wh Bk/Wh 20 A 10 A Clutch Switch Ye/Rd (Manual Transmission) Ye/Rd 10 A Pk/Bu Wh/Og Wh/Gn 10 A ACC - B + A Accessory Accessory Accessory Accessory Accessory Ignition OFF - None Connector 1 Connector 2 Connector 3...
Página 197 TURF TRUCKSTER T ai l Light Bu/Bk Bu/Bk Brake Light Rd/Bk Rd/Bk Single Horn Horn T ail Ligh t Button Harness Bk/Rd Cab Stop Og/Bk Light Accesso r y Brake Wh/Rd Accesso r y Connector 1 Brake Og/Bk Accesso r y Connector 2 Power Point...
Página 198: Gas Engine Schematic
TURF TRUCKSTER 58.1 Gas Engine Schematic Bn/Bk Bn/Wh Air / Fuel Bk/Rd Bk/Rd Ratio Sensor Og/Bk Ye/Bu Gn/Wh Gn/Wh Gy/Bu Ye/Bu Bn/Wh Rd/Bk Rd/Bk Bn/Bk Rd/Ye Gn/Ye Rd/Bu Rd/Bu Bk/Bu Gy/Bu Gn/Bu Bn/Rd Wh/Rd Engine Harness Bu/Wh Wh/Bk ECU Connector Wh/Rd Pins 17, 22, 23, 28, 29 30, 31, 32, 43, 45, 46,...
Página 199 TURF TRUCKSTER Injector #1 Bk/Rd Br/Bk Br/Bk Bn/Wh Bk/Rd Injector #2 Bk/Rd Injector #3 Bk/Rd Bn/Wh Crank Angle Gn/Wh Sensor Rd/Bk Bk/Rd Bk/Rd Rd/Bk Rd/Ye Rd/Bk Rd/Bk Rd/Bu Oxygen Sensor Rd/Ye Rd/Bu Gy/Bu Bk/Rd Bk/Rd Knock Wh/Rd Sensor Bk/Rd Wh/Bk Gy/Bu Crank Position Sensor...
Página 200: Diesel Engine Electrical Schematic
TURF TRUCKSTER Serial No. 84063 All 59.1 Diesel Engine Electrical Schematic Serial No. 84064 All Automatic Transmission Controller Heater Accessory 20 A 10 A Accessory Ye/Rd Clutch Connector 1 Ye/Rd Switch 10 A Accessory Ye/Rd Wh/Gn Connector 2 10 A Accessory Connector 3 ACC - B + A...
Página 201 TURF TRUCKSTER Tail Light Bu/Bk Bu/Bk Rd/Bk Rd/Bk Single Brake Horn Horn Tail Light Light Button Harness Cab Stop Og/Bk Light Accessory Brake Wh/Rd Accessory Connector 1 Brake Og/Bk Accessory Connector 2 Brake Pedal 15 A Switch Wh/Rd Jumper Og/Bk 10 A Wh/Og Wh/Og...
Página 202 TURF TRUCKSTER Rd/Bk Wh/Ye Wh/Ye Wh/Rd Pk/Bu Wh/Bk Rd/Bk Ye** Wh/Bk Wh/Bk**...
Página 203 INDEX 00414-G5....105 11741-85200..85 2700386 ....153 2702501 ....109 009034880.... 81 120052 .51 2700387 ....153 2702502 ....109 01116-G01....103 ..123 2700453 ...... 79 2702534.7 ....131 01421-08303..... 139 120166 ...... 145 2700493 ....133 2702535.7 ....131 01550-08353....59 120177 ..85 2700496 ..51 2702547 ......87...
Página 204 INDEX 303269..75 316942.......145 4140071 ...... 71 4174286 ....85 320107.. 55 4140072 ...... 71 4174287 ...... 71 303952......43 359864.......105 4140075 ...... 71 4174288 ...... 71 304636..75 360111....67 4140090 ....81 4174290 ....101 305134......75 36092-G01....99 4140269 ....47 4174321 ....
Página 205 INDEX 4203360...... 87 450400 ......43 452424 ....57 800021 ....111 4203381...... 87 450401 ......47 452692 ..61 800024 ....103 4205580...... 47 450410 .... 57 452695 43 800026 ......67 4206760...... 43 450412 ....47 452738 ......97 800073 ....91 4208620...... 43 450422 ......
Página 206 INDEX 809174......85 825886..57 832900 ...... 121 837301 ....147 809180....67 825889.......151 833056 ...... 105 837303 ......43 809231....65 825894....147 833101 ...... 105 838154 ...... 111 809254.......135 825899....147 833103 ...... 105 838295.8 ... 101 809265.......121 825961..147 833104 ...... 105 838340 ......
Página 207 INDEX 842104......77 844130 ..51 884513 ...... 125 894179 ......61 842360...... 135 844148 ......73 884574 ...... 121 894201 ....111 842740......64 844177 ......53 885249 ...... 119 894266 ......123 842773....61 844179 ......53 886001 ...... 121 894308 ....57 842774....
Página 210: Calidad, Rendimiento Y Asistencia De Clase Mundial
World Class Quality, Performance And Support Equipment from Jacobsen is built to exacting standards ensured by ISO 9001 and ISO 14001 registration at all of our manufacturing locations. A worldwide dealer network and factory trained technicians backed by Genuine Jacobsen Parts provide reliable, high-quality product support.

Este manual también es adecuado para:

84064 kubota d1105-e3b84067 suzuki k6 mt 84068 suzuki k6 at 84069 suzuki k6 rv

Cushman 84063 Kubota D1105-E3B MT Manual De Piezas Y Mantenimiento

English

1 Safety

2 Vehicle Identification Numbers

3 Specifications

4 Adjustments

5 Maintenance

6 Troubleshooting

7 Maintenance & Lubrication Charts

8 Notes

9 Parts Catalog

Español

1 Seguridad

2 Números de Identificación del Vehículo

3 Especificaciones

4 Ajustes

5 Mantenimiento

6 Resolución de Problemas

7 CUADROS de MANTENIMIENTOY LUBRICACIÓN 7.1 Generalidades

8 Notas

9 Catálogo de Piezas

Enlaces rápidos

Capítulos

Solución de problemas

Resumen de contenidos para Cushman 84063 Kubota D1105-E3B MT