Tabla De Contenido; Important Safety Instructions - Jung Pumpen SGR 125 Manual De Instalación Y Del Operario

Safety
Contents
Important Safety Instructions . . . . . . . . . . . . . . . . . . . . . . .2
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Mo unting Cover and Assembled Rail Sections . . . . . . . . . . 3
Mo unting Cover and Component Rail Pieces . . . . . . . . . . . 4
Attach Pump to Movable Section . . . . . . . . . . . . . . . . . . . . 5
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Product Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Repair Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12

Important Safety Instructions

SAVE THESE INSTRUCTIONS - this manual contains
important instructions that should be followed during
installation, operation, and maintenance of the product.
save this manual for future reference.
this is the safety alert symbol. When you see this
symbol on your pump or in this manual, look for one of
the following signal words and be alert to the potential
for personal injury!
indicates a hazard which, if not avoided, will
result in death or serious injury.
indicates a hazard which, if not avoided,
could result in death or serious injury.
indicates a hazard which, if not avoided,
could result in minor or moderate injury.
NOTICE addresses practices not related to personal injury.
Risk of explosion and hazardous gas .
Improper ventilation of sewer gases can result in leakage
of methane sewer gas, and a possible explosion of fumes,
resulting in severe injury or death.
• Vent basin according to all local codes. Proper
ventilation is needed to prevent negative basin
pressure and to provide air for proper aerobic
activity within the basin.
• Check your local codes before installing. You must
comply with their rules.
• Do not install basin and pump in any location
classified as hazardous by the united states national
electrical Code (neC), or by the Canadian electrical
Code (CeC), where applicable.
For parts or assistance, call Jung Pumpen Customer Service at 1-800-642-5930
• Do not smoke or use sparkable electrical devices or
flame in a septic (gaseous) or possibly septic sump.
• The pumps used with this system are designed
to handle materials which could cause illness or
disease through direct exposure. Wear adequate
protective clothing when working on the pump
or piping.
• If a septic sump condition exists and if entry into
sump is necessary, then (1) provide proper safety
precautions per osHa requirements and (2) do
not enter sump until these precautions are strictly
adhered to.
• Sump covers are used to exclude refuse from the
sump basin. Consult local code for sump cover
specifications.
Hazardous voltage . Can shock, burn, start
a fire, or kill. When installing, operating, or servicing
a sewage pump, follow electrical safety instructions.
only trained service personnel should install or service
this pump.
• Disconnect the pump from the power source before
handling or servicing.
• Any wiring to be done on pumps should be done by
a qualified electrician.
• Never operate a pump with a power cord that has
frayed or brittle insulation.
• Never let cords or plugs lay in water.
• Never handle connected power cords with
wet hands.
• Do not lift pump by the power cord.
• Do not operate pump without all safety devices
in place.
2