Battery Maintenance - AEB ANT B-TWIG 8 MOBILE Manual De Uso

WARNING: To replace the battery, it is recommended to contact qualified and authorized
personnel, i.e. personnel with technical knowledge, experience and specific instructions
sufficient to guarantee safety and correct connection of the power supply terminals.
WARNING: Use only exactly the same battery pack in compliance with the indications and
technical characteristics shown in Fig.2. This specially designed high-performance battery
is the only one approved to ensure safe and effective use with the B-TWIG 8 MOBILE system.
Fig.1

BATTERY MAINTENANCE

Battery maintenance starts as soon as you get hold of a new battery and maintenance
continues for battery entire life cycle. The following table shows the main maintenance activities:
ACTIVITY
Perform a visual inspection
Charge the battery
Store the battery in a state of charge
between 20% and 40%
B-TWIG 8 MOBILE
10 User manual |
Fig.2 - Battery label
RECHARGEABLE LI-ON BATTERY PACK
Model: PL18650/8S2P - 28.8V - 5000mAh
Rated: 28.8V - 5000mAh - 144Wh
Manufacturer Name: GUANGDONG PAILI
Li-ion
NEW ENERGY CO.,LTD
Polarity: Red (+) Black (-)
CAUTION: Risk of fire and burns. Do not open, crush, heat
above 45°C or incinerate. Follow manufacturer's instructions.
ATTENTION: Riques d'ncendie et de brulure. Ne pas ouvrir,
écraser ou faire chauffer a une temperature superieure a 45°C
ou faire bruler. Suivre les instructions du fabricant.
0769003191029
EXECUTION
Before inserting the battery inside the unit.
Check the terminals for correct polarity, red positive (+)
and black negative (-). Check the integrity of the frame
and any dent/perforation.
Upon delivery, after use or in the event of a low battery
indication.
To optimize performance, the battery that is completely
(or almost completely) discharged should be charged as
soon as possible.
When not used for an extended period of time.
PRECAUTIONS FOR USE
Li-ion batteries are characterized by small size with high energy density. Be
careful while handling the battery pack; incorrect or improper use could cause
physical injury and/or material damage.
Strictly follow the following safety instructions:
• Do not short circuit: Make sure the terminals are not in contact with metal or
other conductive materials during transportation and storage.
• Do not drop, crush or pierce the battery. Improper use can cause damage
and internal short circuits, which are not always visible externally.
• Do not install the battery pack with reversed polarity.
• Do not expose the battery to contact with liquids.
• Do not ignite the battery or expose it to temperatures above 60°C degrees.
• Do not attempt to open the battery pack or disassemble the cells inside.
If the battery has dropped or hit a hard surface, regardless of outer frame
condition:
• Immediately stop using.
• Dispose the battery complying with local regulations.
BATTERY LIFE
The life of a Li-ion battery depends on the frequency and duration of use. If used
correctly, the cells inside have a duration of about 500 charge/discharge cycles,
on average 3 years according to the wear associated with daily use. The risk of
battery failures increases with time and with the conditions of use, such failures
can cause the battery to overheat which, in rare cases, can cause the battery
burning or exploding.
DISPOSAL
Before disposal, discharge the battery and insulate the terminals with tape.
Promptly dispose of the used or faulty battery, applying disposal regulations in force.
B-TWIG 8 MOBILE
11
| User manual