Visual Inspection - Amsco 7053L Manual Del Operador

4.2 Visual Inspection

WARNING – PERSONAL INJURY
AND/OR EQUIPMENT DAMAGE
HAZARD: Always load or unload
the Three-level Ophthalmic Rack
with Removable Upper Insert –
Long on appropriate loading cart
or surface.
WARNING – BURN HAZARD:
• Three-level Ophthalmic Rack
with Removable Upper Insert
– Long and
extremely hot when cycle is
completed. Allow rack and
items to cool
temperature and always wear
appropriate
Protective Equipment (PPE)
before reaching into chamber.
• When cycle is completed,
wait until water flow stops
before opening door and
unloading washer/disinfector.
Hot water or steam may be
sprayed through door opening
if door is opened too soon.
Wear appropriate Personal
Protective Equipment (PPE)
whenever reaching
chamber.
4-2
10095339
IMPORTANT: Good Hospital Practices dictate all instruments be
inspected for visible debris after processing in washer. Any
instrument with visible debris must be reprocessed until clean and
free of visible debris prior to terminal processing. Failure to reprocess
until all visible debris have been removed may impede terminal
processing.
1. Remove Three-level Ophthalmic Rack with Removable Upper
Insert – Long from washer/disinfector chamber and place rack
on loading cart.
2. Once items are cool, check each item to detect residues or
debris.
3. Any item that has not been properly cleaned must be
reprocessed in the washer/disinfector until it is clean.
4. When inspection is completed and all instruments and items are
properly cleaned, carefully empty the upper section of the rack.
Ensure that all flexible tubes are disconnected from the
instruments.
items are
5. Slide out ophthalmic baskets from the lower section of the rack.
6. See S
to room 7053L
Manual (10085881), to properly unload the Three-level
Personal Ophthalmic Rack with Removable Upper Insert – Long.
IMPORTANT: STERIS recommends unloading Three-level
Ophthalmic Rack with Removable Upper Insert – Long on an
appropriate surface or work table.
into
Operator Manual
4.7, U
ECTION NLOADING
S -C
INGLE HAMBER
W /D , in AMSCO
ASHER ISINFECTOR
W /D
ASHER ISINFECTOR
Unloading Instructions
Operator