Lighting; Lighting Instructions; Lighting The Burner; If Burner Does Not Ignite Or Burner Extinguishes - Broil King Smoke Vertical Gas Manual Del Usuario

LIGHTING

A. BURNER CONTROL
B. IGNITOR
C. NATURAL GAS HOSE
D. DOOR
E. HANDLE

LIGHTING INSTRUCTIONS

1. The appliance must be assembled as per the assembly
instructions.
2. Ensure there are no gas leaks in the gas supply system.
See: "Leak Testing." (page 6)
3. Ensure that the venturi tubes are properly located over
the gas valve orifice. (see Venturi diagram, page 6)
4. Ensure that the Main Burner ignition wire is connected.
5. Carefully review all instructions on the information plate
attached to the smoker.
6. WARNING: Always open the door before lighting and do
not lean over the smoker while lighting.
7. Set control knobs to "OFF" and turn on the gas supply.

LIGHTING THE BURNER

a. Open the smoker door and leave open until lit.
b. Check that the battery has been installed in the
electronic ignition.
c. Push and turn the burner control knob to "HIGH."
d. Push and hold down the ignitor button or use match to
light.
e. Burner should ignite within 5 seconds; turn off gas
source immediately if ignition does not occur in this
timeframe. To light burner with a match proceed below
to step f
f. Attach match to the match light chain and light.
g. Lower lit match to the burner.
h. Push and turn the burner control knob to "HIGH."
i. Burner should ignite within 5 seconds.
CAUTION - Check your gas smoker after lighting. All
burner ports should show a 1in / 2.5cm flame on "HIGH."
If any of the following symptoms occur there is probably a
blockage in the venturi tubes. Shut off gas at once and
clean the venturi tubes. See "Venturi Tubes." (page 6)
1. You smell gas.
2. A flashback fire occurs.
3. Your Smoker heats unevenly.
4. The burner make popping noises.
IF BURNER DOES NOT IGNITE OR BURNER
EXTINGUISHES:
Push and turn control knob to "OFF." Wait 5 minutes
1.
then try again with control knob set at "MEDIUM."
If the burner will not light, see "Troubleshooting" on
2.
page 11. If problems persist, do not attempt to operate
the appliance; contact OMC, your dealer or an approved
service center.
SHUTDOWN:
1. Turn off gas supply.
2. Turn control knobs to "OFF."
Match lighting the burner using the match light chain.
7