Publicidad
Idiomas disponibles
Idiomas disponibles
Run a drain line from the evaporator coil drain
to the pump. Use flexible plastic pipe where
the code permits. Insert the pipe 1" below the
pump cover hole*. Locate the highest point
above the pump (no more than recommended
lift of unit) and fasten the 3/8" tubing. Be
careful not to kink it. This will block the flow. At
the top of the rise turn the tubing 90º for
horizontal run. For good flow, slant the
horizontal run downward toward the drain.
3/8" I.D. plastic tubing is available from
distributor. 3/8" O.D tubing may be used,
remove barbed check valve and add CB8
check valve.
Turn the electric power off at the fuse box before making any line voltage connections.
LOW VOLTAGE – Two pigtails are provided for
low voltage wiring. Connect blue lead to "Y"
terminal on relay; connect other blue lead to "Y"
terminal on thermostat.
To test safety float switch, temporarily stop
flow of discharge line by sharply bending vinyl
tubing. Pour more water into pump inlet. Water
level will rise beyond high level of control float
until safety float switch breaks the "Y"
thermostat circuit shutting down air conditioner
condensing unit. Unbend the tube and the
pump will empty the entire sump. Replace inlet
line into pump inlet.
TESTING – Temporarily remove inlet tubing
connecting evaporator drain to pump. Pour
water slowly into pump inlet. Control float
should rise until snap switch turns on pump.
MAINTENANCE AND TROUBLE SHOOTING
1.
2.
3.
4.
Each Beckett Corporation ("Beckett") product is warranted to be free from defects in material and workmanship for the applicable Warranty Period (herein so called) set forth below. The Warranty Period for each
product commences on the date of purchase by the original purchaser. The Warranty Periods are as follows:
Product Type or Name
Pump Models:
FR Series, DP800-1800, G Series, W Series ............2 Years
UL6500A; XL-6500A.......................... 2 Years
Other Pump Models............................1 Year
Pre-Formed Poly Ponds....................................... 15 Years
Waterfall Weir & Skimmer...................................... 5 Years
APPLICATION: The warranty covers only properly installed and maintained Beckett products and is limited to application at normal temperature 32º F to 86º F, (0º C to 30º C) pumping fluids with a specific gravity
up to 1.1 and with a pH range of 5 to 9 (fresh water). Other liquid applications and extreme temperature uses must be approved in advance by Beckett. The warranty does not apply to or cover damages or defects
caused by external causes, including, but not limited to, improper or faulty installation or unauthorized modification, lightning, electrical surges, abuse, misuse or abnormal use or misapplication, including use in a
manner inconsistent with the product's intended function. The purchaser is responsible for determining the suitability of the product for its intended use. If products are damaged in transit, a claim should be filed
with the carrier.
REMEDY: If there has been a failure to conform to the warranty, Beckett will, at Beckett's option, repair, replace or issue a credit or refund for the particular nonconforming product or part. Repair, replacement,
credit or refund, at Beckett's option, is the exclusive remedy in the event of a failure to conform to the warranty. Warranty claims must be made within 3 months after expiration of the applicable Warranty Period.
ADMINISTRATION: Warranty claims must be made by returning the nonconforming Beckett product, freight prepaid, along with proof of purchase, to: Beckett Corporation, Customer Service Dept., Irving, Texas,
telephone (888) 232-5388. Telephone authorization from Beckett is required prior to returning nonconforming products or parts. All products or parts returned will be inspected to determine cause of failure before
warranty is approved.
INSTALLATION, REMOVAL AND/OR SHIPPING CHARGES: The warranty does not cover any costs associated with the installation, removal or shipping of products subject to warranty claims.
DISCLAIMER AND LIMITATION: THE EXPRESS WARRANTY AND REMEDIES SET FORTH ABOVE ARE EXCLUSIVE AND IN LIEU OF ALL OTHER WARRANTIES AND REMEDIES, WHETHER ORAL OR
WRITTEN, EXPRESS OR IMPLIED. TO THE FULL EXTENT PERMITTED BY LAW, BECKETT EXPRESSLY DISCLAIMS ANY AND ALL IMPLIED WARRANTIES, INCLUDING, WITHOUT LIMITATION, THE
IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. IF IMPLIED WARRANTIES CANNOT BE DISCLAIMED, ALL SUCH IMPLIED WARRANTIES ARE LIMITED
TO THE DURATION OF THE APPLICABLE EXPRESS WARRANTY.
BECKETT DOES NOT ACCEPT LIABILITY BEYOND THE REMEDIES EXPRESSLY SET FORTH IN THIS WARRANTY. IN NO EVENT SHALL BECKETT BE LIABLE OR RESPONSIBLE FOR INCIDENTAL OR
CONSEQUENTIAL DAMAGES. BECKETT'S AGGREGATE LIABILITY UNDER THIS WARRANTY OR WITH RESPECT TO ANY PRODUCT COVERED HEREBY, UNDER ANY LEGAL THEORY, SHALL NOT
EXCEED THE PURCHASE PRICE PAID FOR THE NONCONFORMING PRODUCT. THE LIMITATIONS CONTAINED IN THIS PARAGRAPH SHALL NOT APPLY TO INJURY TO THE PERSON.
Some States do not allow the exclusion or limitation of incidental or consequential damages or exclusions or limitations on the duration of an implied warranty, so the above limitations or exclusions may not apply to
you. This warranty gives you specific legal rights and you may also have other rights that vary from State to State.
The wiring must comply with local codes.
Safety Switch
Wiring for CB22
Remove dirt that may collect in bottom sump.
Look at vinyl DISCHARGE LINE to see that it is open and water can pass through freely.
Always replace cover to keep electrical parts clear of dust and grime.
See item 7 of Introduction.
Warranty Period
PIPING
Barbed
Checkvalve
Designated
Pump Lift
WIRING
WARNING
Green Ground
Conn.
Blue
Safety Micro Switch
LIMITED WARRANTY
Product Type or Name
Liner Material:
35 mil PVC.........................................20 Years
40 mil EPDM.......................................20 Years
20 mil PVC.........................................15 Years
UV9/UV13 Filter.................................. 1 Year
All Other Beckett Products..................................90 Days
3/8" Plastic Tubing
Attach to
"Y" on Relay
"Y" on Thermostat
NEC. Class 2
(Low Voltage)
Blue
Warranty Period
92346 Rev. 01
Evaporator
("A" Coil)
*Drain Tube
(3/4")
1"
Publicidad
