Publicidad
For your own personal protection and for the safety of those around you, please read and ensure you fully understand the following
safety information. It is the responsibility of the operator to ensure that he/she fully understands how to operate this equipment safely.
If you are unsure about the safe and correct use of the 'RPC', consult your supervisor or Altrad Belle.
Improper maintenance can be hazardous. Read and Understand this section before you perform any
CAUTION
maintenance, service or repairs.
•
This equipment is heavy and must not be lifted single-handedly, either GET HELP or use suitable lifting equipment.
•
Cordon off the work area and keep members of the public and unauthorised personnel at a safe distance.
•
•
Make sure you know how to safely switch this machine OFF before you switch it ON
•
Always switch OFF the engine before transporting, moving it around the site or servicing it.
•
During use the engine becomes very hot, allow the engine to cool before touching it. Never leave the engine running and
unattended.
•
if any are damaged or missing, DO NOT USE THE COMPACTOR until the guard has been replaced or repaired.
•
CAUTION
Fuel Safety.
•
Before refuelling, switch off the engine and allow it to cool.
•
When refuelling, DO NOT
•
Spilt fuel must be made safe immediately, using sand. If fuel is spilt on your clothes, change them.
•
Store fuel in an approved, purpose made container away from heat and ignition sources.
Vibration
Some vibration from the compaction operation is transmitted through the handle to the operator's hands. The Altrad Belle RPC range
PPE (Personal Protective Equipment)
Suitable PPE must be worn when using this equipment i.e. Safety Goggles, Gloves, Ear Defenders, Dust Mask and Steel Toe capped
equipment's moving parts. Always protect skin from contact with concrete.
Dust
The compacting process will occasionally produce dust, which may be hazardous to your health. Always wear a mask that is suited to
the type of dust being produced.
Fuel
Do not ingest fuel or inhale fuel vapours and avoid contact with your skin. Wash fuel splashes immediately. If you get fuel in your eyes,
irrigate with copious amounts of water and seek medical attention as soon as possible.
Exhaust Fumes
WARNING
The exhaust fumes produced by this equipment are highly toxic and can kill!
Pre start-up inspection
The following Pre-start-up inspection must be performed before the start of each work session or after every four hours of use, which-
1. Thoroughly inspect the compactor for signs of damage. Check components are present and secure. Pay special attention to the
belt guard.
2. Check the engine oil and hydraulic oil level and top up as necessary.
3. Check the engine fuel level and top up as necessary.
4. Check for fuel, oil and hydraulic leaks.
General Safety
Health & Safety
Health & Safety
16
-
Publicidad
