Start-Up Report - Barnes 3SE-HD Serie Manual De Instalación

This form is designed to provide assurance that customer service and a quality product are the number one priority with
Crane Pumps & Systems, Inc (CP&S). Please fi ll out the following questions as completely and accurate as possible.
When complete, mail this form to:
In U.S.A Send To:
Crane Pumps & Systems, Inc
Attn: Warranty Service Group
420 Third Street
Piqua, Ohio 45356
REPORTS THAT ARE NOT RETURNED CAN DELAY OR VOID WARRANTY.
Pump Owner's Name:
Address:
Location of Installation
Person in Charge
Purchased From (Crane Pumps & Systems Representative/Distributor
Pump Model
Part Number
Voltage Phase
Rotation: Direction of impeller rotation (Use C/W for clockwise, CC/W for counter-clockwise)
Method used to check rotation (viewed from bottom)
Does impeller turn freely by hand:
Condition of equipment
Condition of cable jacket
Resistance of cable jacket
Resistance of cable and pump motor (measured at pump control)
Red-Black Ohms, Red-White
Resistance of Ground Circuit between Control Panel and outside of pump
MEG Ohms check of insulation:
Red to Ground
Condition of equipment at Start-Up: Dry
Was Equipment Stored?
Describe station layout
Liquid being pumped
Debris in bottom of station?
Was debris removed in your presence?
Are guide rails exactly vertical?
Is BAF stationary installed level?
Liquid level controls: Model
Are level controls installed away from turbulence?
Operation Check:
Tip lowest fl oat (Stop Float), All pumps should remain off.
Tip second fl oat (and Stop Float), one pump comes On.
Tip third fl oat (and Stop Float), both pumps on (alarm on simplex).
Tip fourth fl oat (and Stop Float), high level alarm on (omit on simplex).
If not CP&S level controls, describe type of controls
Does liquid level ever drop below volute top?

START-UP REPORT

FOR SUBMERSIBLE PUMPS
Hertz
Yes No
Good Fair
Good Fair
Good Fair
Ohms, White-Black
White to Ground
Wet
Length of Storage
19
In Canada Send To:
Crane Pumps & Systems, Inc.
Attn: Service Manager
83 West Drive, Brampton
Ontario, Canada L6T 2J6
Phone
Serial No.
Horespower
Poor
Poor
Poor
Ohms
Ohms
Black to Ground
Muddy
E
N
G
L
I
S
H