Maintenance Interval Chart - SELVA MARINE Dolphin 9.9 Manual De Servicio

INSP
ADJ

MAINTENANCE INTERVAL CHART

The following chart should be considered strictly as a guide to general maintenance intervals.
Depending on operating conditions, the intervals of maintenance should be changed.
Item
COWLING:
Water separator drain hole
FUEL SYSTEM:
Fuel line
Fuel filter
CONTROL SYSTEM:
Throttle cables
Remote control throttle cable
Throttle link lever
Remote control shift cable
Engine idling speed
Start-in-gear protection device
POWER UNIT:
Engine oil
Oil filter
Timing belt
Valve clearance
Ignition timing
Thermostat
Water leakage
Motor exterior
Exhaust leakage
Cooling water passage
LOWER UNIT:
Gear oil
Impeller
Lower unit leakage
Propeller
GENERAL:
Anode
Battery
Spark plug
Wiring and connector
Bolts and nuts
Lubrication points
MAINTENANCE INTERVAL CHART
Remarks
Inspect
Inspect
Inspect/replace
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/change
Replace
Inspect/replace
Inspect/adjust
Inspect
Inspect /replace
Inspect
Inspect
Inspect
Inspect/clean
Change
Inspect
Inspect
Inspect
Inspect
Inspect
Cleaning/adjust/
replace
Adjust/reconnect
Tighten
Lubricate
Initial
10 hours 50 hours
(Break-in) (3 months)
1
1 1
1
1
1
1
1
1 1
1
1 1
1
1
1
1
1
EVERY MONTH
1 1
1
1
3-1
Every
Refer
100 hours 200 hours
page
(6 months) (1 year)
1
1
1
4-3, 3-2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
6-4, 6-29
1
1
1
1
1
1
1
E
3-2
3-2
3-3
3-4
3-5
3-6
3-8
3-10
3-11
3-11
3-12
3-12
3-14
5-34
—
—
—
—
3-15
3-16
—
3-16
3-17
—
3-18
—
—
3-21