Bleeding.and.filling.brake....25 Des.supports.de.patin; Changing.brake.shoes - Magura HS 11 Manual De Instrucciones

c
Hanging Brake sHOes
Danger of accident due to brake failure caused by faulty installation.
Use.only.original.MAGURA.brake.shoes.appropriate.for.your.rim.type.
Î –
There.are.4.different.original.MAGURA.brake.shoe.blends:.
L L
Black.–.Standard.for.uncoated.aluminium.rims.
Red.–.High­grip.blend.for.uncoated.aluminium.rims.
Grey.–.Standard.for.anodised./coated.aluminium.rims.
Green.–.High­grip.for.anodised./coated.aluminium.rims
Screw.the.adjusting.screw.(TPA).
) .
[ ]
out.as.far.as.the.stop. ­ .
B4
( )
Open.the.brake.– see.
O
) .
pening tHe Brake fOr dis
Remove.the.wheel.
) .
[ ]
Pull.off.worn.brake.shoes.
J1
) .
Clean.the.brake.shoe.holders.
) .
Push.on.new.brake.shoes.–.allow.them.to.engage.
) .
Install.the.wheel.
) .
Apply.the.brake.– see.
a
) .
pplying tHe Brake
Danger of accident caused by brake failure.
Pull.and.hold.the.brake.lever.and.check:.
Î –
that.no.oil.is.leaking.from.any.part.of.the.brake.system..
Brake.pads.are.in.full.contact.with.the.brake.track.area.
Pressure.point.is.clearly.noticeable.and.does.not.change.
Danger of accident by bursting tires.
Make.sure.that.the.brake.pads.cannot.contact.the.tires.
Î –
Set.the.pressure.point.– see.
s
) .
etting tHe pressure pOint
,.page.23.
wear
( 6 ) .on.the.corresponding.brake.lever.
,.page.23.
-/
mOunting tHe wHeel
,.page.23.
[ ]
.
( 1 ) F1
/
cOmpensating fOr pad
B
leeding and filling Brake
EBT.(Easy.Bleed.Technology).makes.it.easy.to.bleed.the.brake.
L L
The.only.difference.between.bleeding.and.filling.–.if.any.–.is.the.amount.
L L
of.oil.required.–.the.procedure.is.identical.
Always.fill.at.the.brake.cylinder,.never.at.the.brake.lever!
L L
loss of oil and irreparable damage to the braking system.
Î – Open.the.screw.plugs.for.bleeding.and.filling.only.
Use.MAGURA.Royal Blood.(mineral.oil).exclusively.for.bleeding.and.
Î –
filling.–.never.DOT.brake.fluid.
Because.MAGURA.Royal Blood.does.not.age,.it.is.not.necessary.to.
L L
bleed.or.refill.your.MAGURA.brake.regularly..Do.this.only.if.one.of.the.
following.reasons.requires.it:
The.brake.does.not.respond.immediately.when.the.brake.lever.is.actu­
Î Î
ated.
Pressure.point.is.not.clearly.defined,.it.is.spongy.or.does.not.remain.
Î
Î
constant.
After.changing.the.brake.hose.
Î Î
To.bleed.or.fill.your.MAGURA.brake.you.will.need.the.MAGURA.Service
L L
Kit.or.the.MAGURA.Pro Bleed Kit.–.available.from.dealers.
Insert.barbed.fitting. .tightly.into.the.filling.line.by.hand.
( 1 )
) .
Fill.filling.syringe. ( 2 ) .with.MAGURA.Royal Blood.
) .
Make.sure.that.there.is.no.air.in.the.filling.syringe.and.filling.line.
) .
Remove.the.piston.of.the.bleeding.syringe.
) .
Make.sure.that.the.pressure.point.adjusting.screws.(TPA).
) .
[ ]
. u nscrewed.to.the.stop.(­). .
B4
m
aintenance
[ ]
.
l1
.
( 3 )
.are.
( 6 )
25