Maintenance; Maintenance Table - THERMOBILE IMA US Manual Del Usuario

English
5

MAINTENANCE

5.1

Maintenance table

After each winter season, record the maintenance
in the table at the back of this book.
Description
Check the pump for leakage, corrosion and dirt.
Check the pump, fans, ignition, photocell, burner, electrical installation and heat exchanger
for general condition.
Check the fuel line for obstruction, corrosion and leakage.
Check the fan of the burner for corrosion and dirt.
Check the fan for corrosion and dirt.
Clean the filters of the pump, magnetic valve.
Check the photocell for damage. Make sure the photocell is free from dust and sediment.
Check the adjustment of the electrodes.
Check the nozzle, dust etc.
Clean the fuel filter with white spirit.
Clean the heat exchanger.
Clean the inlet/outlet.
Check the V-belts.
Hot
Do not touch the flue and air outlet!
Wait until the flue and the air are cooled
down before maintenance.
5.2 General
Warning
Disconnect the electric power during
maintenance!
When you store the heater for a long period:
1. Let the heater burn for 3 minutes. This
protects the pump against corrosion.
2. Keep the burner head free from dust and
sediment.
A dirty burner head causes bad combustion
that makes soot and carbon and damage to
the burner chamber.
3. Close the valve for the fuel supply.
4. Disconnect the electric power.
5.3 Adjustment air inlet and electrodes
(Fig. 9)
A Distance nozzle-electrode
B Height nozzle centre-electrode
C Distance of electrodes
10
/i
5.4
1. Remove the glass of the filter.
2. Remove the filter.
3. Clean the filter. Replace if necessary.
4. Assembly in the opposite way.
5.5
Check the photocell:
1. Remove the rain cover (A) of the heater, see
fig. 5.
2. Remove the cover of the burner.
3. Loosen the screw (A) of the burner relay a
few turns.
4. Remove the burner relay completely. The
photocell is located at the front of the burner
relay.
5. Clean the photocell (B) if the glass has
turned black.
If the glass is cracked: the photocell must be
replaced by the dealer.
Install the photocell in the reverse order.
40.020.940 - rev. 04 - 2011
Filter
Photocell (Fig. 10)
Period
Yearly
User
Dealer
User
User
User
Dealer
User
Dealer
Dealer
User
Dealer
User
User
IMA-US